| Most common failures | No# failures |
|---|
| Registration plate issues | 31 |
| Headlamp aim out of alignment | 30 |
| Windscreen wiper does not clear the windscreen effectively | 27 |
| Registration plate lamp issues | 22 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 18 |
| Windscreen washer not working | 12 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 11 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 5 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 5 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Front Shock absorbers has a serious fluid leak | 4 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 3 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 3 |
| Brake hose damaged | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 3 |
| Offside Front Suspension arm ball joint excessively worn rear arm (5.3.4 (a) (i)) | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Windscreen has damage | 3 |
| Offside Front Suspension arm ball joint excessively worn rear |5.3.4 |a| |i|| | 3 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 2 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Front All position lamps not working |1.1.A.3b| | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Road wheel cracked |4.2.A.1a| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 2 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Headlamp cleaning device inoperative |1.7.2| | 2 |
| Offside Front Headlamp cleaning device inoperative |1.7.2| | 2 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 2 |
| Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt Both sides (5.3.4 (b) (ii)) | 1 |
| Offside Rear Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn [rear arm] (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn FRONT BUSH (5.3.4 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn break force arm bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn break force arm bush (5.3.4 (a) (i)) | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn rear arm (5.3.4 (a) (i)) | 1 |
| Offside Windscreen wiper missing (3.4 (a)) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Road wheel fractured inner rim |5.2.2 |a|| | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Front Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Offside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Emissions not tested NOT TESTED DUE TO ENGINE MISSFIRE (8.2.1.2 (d)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn INNER ARM BUSH WORN TO EXCESS (5.3.4 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Windscreen in an unacceptable condition More than 40mm in swept area (3.2 (c) (i)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Outer Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn outer bushes (5.3.4 (a) (i)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn rear off front (5.3.4 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Front Brake disc significantly and obviously worn inner face visually worn |1.1.14 |a| |i|| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction sunvisor (3.1 (a) (ii)) | 1 |
| Nearside Front Inner Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn Trailing /Rearmost |5.3.4 |a| |i|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Steering linkage ball joint has excessive play Bottom ball joint. (2.1.3 (b) (i)) | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Rear Seat belt buckle not functioning as intended |7.1.2 |d|| | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension arm ball joint excessively worn rear arm - needs full suspension recheck (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint rear |2.4.G.2| | 1 |
| Offside Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Front Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Rear Road wheel fractured Inner rim (5.2.2 (a)) | 1 |
| Nearside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Nearside Headlamp levelling device inoperative |1.7.2| | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative lack of water |4.1.6 |a| |ii|| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Parking brake lever ratchet not holding correctly |1.1.6 |a|| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |8.2.1.2 |g|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Nearside Rear Road wheel badly damaged |4.2.A.1a| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn rear (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn Rear arm (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt Rear arm (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush rear |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn lower rear arm ball joint (5.3.4 (a) (i)) | 1 |
| Nearside Front Fluid leak harmful to the environment or a risk to other road users (8.4.1 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Brake lever pivot has excessive wear or free play (1.1.1 (b)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt rear arm (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt n/s o/s front (5.3.4 (b) (ii)) | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Nearside Rear Road wheel fixing missing wheel bolt missing (5.2.1 (a) (i)) | 1 |
| Offside Front Exhaust has a major leak of exhaust gases pipe to middle pipe (6.1.2 (a)) | 1 |
| Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint rearward arm ball joint |2.4.G.2| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Offside Rear Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen has no washer fluid to front windscreen |3.5 |a|| | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |