| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 26 |
| Headlamp aim out of alignment | 22 |
| Brake pipe excessively corroded | 17 |
| Rear parking brake recording little or no effort | 16 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Registration plate lamp issues | 11 |
| Brake hose excessively deteriorated | 8 |
| Anti-lock braking system warning lamp indicates an ABS fault | 7 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 7 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Registration plate issues | 6 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 5 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Centre Stop lamp not working |1.2.1b| | 3 |
| Rear brake binding | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Rear coil spring fractured |2.4.C.1a| | 3 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Service brake excessively fluctuating Both sides |1.2.1 |e|| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded Sill |5.2.6| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced full length inner sill panel (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill panel full length sill panel (7.1.1 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt inner ball joints (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt inner ball joints (5.3.4 (b) (ii)) | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Centre Front Upper Windscreen is of a temporary type |8.3.1f| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Shock absorber casing damaged externally so the unit does not function base plate falling away
|2.7.2a| | 1 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Front Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Outer Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Windscreen has damage | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Fuel system component leaking |7.2.3| | 1 |
| Front brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Brake hose damaged | 1 |
| Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Outer Rear Lower Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Windscreen washer not working | 1 |