| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear parking brake recording little or no effort | 6 |
| Registration plate lamp issues | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Horn not working |1.6.2a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake pipe excessively corroded | 2 |
| Brake hose excessively deteriorated | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Nearside Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect dipping wrong way (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect dipping wrong way (4.1.2 (c)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength upper spring mount (5.3.6 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases rear back box rusted (6.1.2 (a)) | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Inner Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Offside Inner Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |