| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 13 |
| Headlamp aim out of alignment | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Rear parking brake recording little or no effort | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brakes imbalanced across an axle | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Registration plate issues | 2 |
| Rear brake binding | 2 |
| Nearside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust emissions hydrocarbon content excessive 3464ppm |8.2.1.2 |b|| | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Sub-frame pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Fuel pipe leaking By fuel filter |6.1.3 |b| |i|| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Fuel pipe leaking from tank. |7.2.3| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Windscreen has damage | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear Drive shaft uj which forms part of the suspension has a loose flange bolt |2.4.G.4c| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Side repeater missing |4.4.1 |a| |ii|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Front Electrical wiring likely to drag on the ground |4.11 |a| |iii|| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill + jacking point (7.1.1 (a) (i)) | 1 |
| Offside Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |