| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 16 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Brake hose excessively deteriorated | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Registration plate issues | 3 |
| Headlamp aim out of alignment | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Roller brake test indicates a sticking brake |3.3.A1a| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Rear brake binding | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel stud|s| loose |4.2.A.1e| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength both front & rear outer sills |5.3.6 |a| |i|| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen has damage | 1 |