| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 50 |
| Parking brake: efficiency below requirements |3.7.B.7| | 44 |
| Registration plate lamp issues | 26 |
| Rear parking brake recording little or no effort | 22 |
| Brake pipe excessively corroded | 16 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 11 |
| Parking brake lever has no reserve travel |3.1.6b| | 9 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Front Direction indicator not working |1.4.A.2c| | 6 |
| Front brake application uneven | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 4 |
| Brakes imbalanced across an axle | 4 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 4 |
| Registration plate issues | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 2 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 2 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 2 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Parking brake: efficiency below requirements |3.7.D.4| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 2 |
| Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 2 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear Brake lever has abnormal movement of levers indicating maladjustment |3.5.1f| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Nearside Rear Brake pipe fouled by moving parts shock bush |3.6.B.2a| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Upper Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| front brake juddering severely |3.7.A.2b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Outer Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Inner Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Upper Tie bar/rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Fluid suspension leaking |2.4.D.2| | 1 |
| Power steering ram leaking |2.1.5 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Power steering component leaking rack |2.1.5 |a|| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
| Brake hydraulic reservoir fluid level significantly below minimum level |1.1.10 |d| |ii|| | 1 |
| Nearside Inner Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam H4 bulb fited |4.1.1 |a| |ii|| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Outer Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Inner Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Macpherson strut inappropriately repaired |2.4.A.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Parking brake lever missing |3.1.3a| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Central Front Power steering component|s| leaking Steering Control Rack |2.3.3b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Fluid suspension has no suspension movement |2.4.D.5| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Front Parking brake lever missing park brake lever missing|release| |3.1.3a| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Lower Macpherson strut mounting corroded and seriously weakened Spring carrier |5.3.3 |b| |i|| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside brake disc contaminated by oil |3.5.1h| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front position lamp|s| not working main beam headlamp |1.1.A.3b| | 1 |
| Centre Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside Rear Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
| Parking brake lever ratchet mechanism worn to the extent that the brake may inadvertently release |1.1.6 |b| |ii|| | 1 |
| Offside Rear Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front position lamp(s) not working (1.1.A.3b) | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected OUTTER SILL (5.3.6 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Nearside Front Lower Macpherson strut ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Headlamp lens seriously defective insecure (4.1.1 (b) (ii)) | 1 |
| Nearside Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Rear Brake disc contaminated (1.1.14 (b)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp lens missing (4.1.1 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Hydraulic fluid leaking excessively braided hoses to junction connection hydraulic fluid over hoses (8.4.1 (a) (i)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Steering locking device missing all 4 on track rod ends (2.1.3 (d)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Rear Coil spring mounting corroded and seriously weakened lower spring cup (5.3.1 (b) (i)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Central Steering locking device missing 4 locking pins missing at steering rack (2.1.3 (d)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |