| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 24 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Parking brake lever has no reserve travel |3.1.6b| | 10 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Registration plate lamp issues | 6 |
| Rear parking brake recording little or no effort | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Brake pipe excessively corroded | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Steering rack has excessive free play detected at the steering wheel to the extent that safe steering is affected |steering rack fitted| |2.3 |a| |ii|| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Lower Macpherson strut ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake lever, pawl mechanism pivot|s| retaining device insecure Handbrake release handle adrift |3.1.4b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Headlamp aim projected beam image is obviously incorrect both |4.1.2 |c|| | 1 |
| Nearside Front Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Horn not working (7.7 (a)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated release lever broken (1.1.6 (d)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Position lamp adversely affected by the operation of another lamp headlamps come on with side lamps (4.2.3 (c)) | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Brake cable has restricted free movement (1.1.15 (e)) | 1 |
| Parking brake lever missing release pull |3.1.3a| | 1 |
| Offside Front Sub-frame has excessive play in a pin/bush companion mounting |2.4.G.2| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear brake binding | 1 |
| Rear Exhaust system not adequately supported silencer mounting |7.1.1| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Engine mounting damaged or deteriorated resulting in excessive movement |6.1.8 |a| |i|| | 1 |
| Nearside Rear Engine mounting damaged or deteriorated resulting in excessive movement |6.1.8 |a| |i|| | 1 |
| Power steering ram leaking |2.1.5 |a|| | 1 |
| Nearside Rear Suspension unit leaking sub frame shocker |5.3.5 |c|| | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn rear arm bush |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment warning light on (1.1.6 (c)) | 1 |
| Windscreen washer not working | 1 |
| Offside Rear Brake clevis joint has restricted free movement seized allowing cable to rub exhaust (1.1.15 (e)) | 1 |
| Parking brake lever is not capable of being maintained in operation by direct mechanical action only (1.1.6 (f)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Brake performance not tested park brake (1.2.1 (g)) | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Centre Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |1.1.16 |b| |i|| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Power steering component|s| leaking steering rack |2.3.3b| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Parking brake efficiency below requirements |3.7.E.1| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Headlamp not working on dipped beam Offside |1.7.5a| | 1 |
| Headlamp not working on dipped beam Nearside |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |