| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Headlamp aim out of alignment | 12 |
| Registration plate lamp issues | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Brake pipe excessively corroded | 6 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Horn not working |1.6.2a| | 3 |
| Registration plate issues | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Windscreen wiper blade insecure | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded step sill |5.2.6| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases incomplete at tail pipe |7.1.2| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Seat belt anchorage prescribed area strength or continuity significantly reduced Offside sill |7.1.1 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Jacking point |5.3.6 |a| |i|| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar insecure d bush missing |2.4.G.1| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Side repeater does not face the side (4.4.3 (a)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen washer not working | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Rear Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Nearside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Anti-roll bar fractured |2.4.G.1| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Towbar component insecure |6.6.1| | 1 |
| Nearside Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Headlamp lens seriously defective both (4.1.1 (b) (ii)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
| Offside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member |6.1.1 |c| |i|| | 1 |