| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 35 |
| Registration plate lamp issues | 12 |
| Horn not working |1.6.2a| | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Headlamp aim out of alignment | 8 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Brakes imbalanced across an axle | 6 |
| Rear brake binding | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Brake pipe excessively corroded | 4 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 3 |
| Rear brake application uneven | 3 |
| All direction indicators not working (4.4.1 (a) (ii)) | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 2 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Fuel system component leaking (6.1.3 (b) (i)) | 2 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Brake hose excessively deteriorated | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Battery insecure |1.9.1| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Brake hose damaged | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp lens seriously defective / nearside (4.1.1 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting rear of inner wheel arch near jacking point (6.2.2 (d) (i)) | 1 |
| Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced crossmember (6.1.1 (c) (i)) | 1 |
| Front Service brake excessively fluctuating both |1.2.1 |e|| | 1 |
| Front Service brake excessively binding both |1.2.1 |f|| | 1 |
| Nearside Rear Upper Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Upper Suspension spring mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| An item not tested |Manual| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength In arch upper |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength In arch upper |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength In arch lower |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Jacking block area |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Jacking block area |5.3.6 |a| |i|| | 1 |
| Nearside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Outer sill below drivers door heavily corroded. (6.1.1 (c) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Central Stop lamp|s| with a multiple light source more than 1/2 not functioning |4.3.1 |a| |ii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Offside Headlamp lens seriously defective |4.1.1 |b| |ii|| | 1 |
| Nearside Front Cab or chassis has excessive corrosion to the extent that overall security or stability of the cab is impaired inner wheel arch (6.2.2 (d) (ii)) | 1 |
| Offside Front Cab or chassis has excessive corrosion to the extent that overall security or stability of the cab is impaired inner wheel arch (6.2.2 (d) (ii)) | 1 |
| Central Seat belt buckle missing (7.1.2 (d)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill/step (6.2.2 (d) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill step (6.2.2 (d) (i)) | 1 |
| Registration plate issues | 1 |
| Nearside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected out rigger |5.3.6 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch at rear and along chassis (5.3.6 (a) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch along chassis (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch near top (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength step (5.3.6 (a) (i)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded (2.1.2 (e) (i)) | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded (2.1.2 (e) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Nearside Brake cable damaged (1.1.15 (a)) | 1 |
| Offside Brake cable damaged (1.1.15 (a)) | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking piont (6.2.2 (d) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength chassis on front crossmember mount (5.3.6 (a) (i)) | 1 |
| Nearside Front Seat belt damaged |7.1.2 |b| |i|| | 1 |
| Electrical wiring insecure and in contact with sharp edges Under front crossmember (4.11 (a) (ii)) | 1 |
| Offside Rear Lower Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel system component leaking possible fuel filter (6.1.3 (b) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis and outrigger (5.3.6 (a) (i)) | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded INNER AND OUTER SILL |5.2.6| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded CHASSIS/OUT RIGGER |2.4.A.3| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch to outer sill holed (6.1.1 (c) (i)) | 1 |
| Offside Front Upper Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced holed by inner plastic wheel arch (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point holed (6.1.1 (c) (i)) | 1 |
| Offside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced side step holed by prevoiusly welded area (6.1.1 (c) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch x3 places (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch by strut (5.3.6 (a) (i)) | 1 |
| Front Oil leaking excessively from engine sump |8.4.1 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing at strut support |5.3.6 |a| |i|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel third axle |1.3.1 |a| |i|| | 1 |
| Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel second axle |1.3.1 |a| |i|| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength suspension turret (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength suspension turret (5.3.6 (a) (i)) | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded rear mounting |2.4.A.3| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Position lamp not working llb501 |4.2.1 |a|| | 1 |
| Offside Front Headlamp not working on dipped beam h7 |4.1.1 |a| |ii|| | 1 |
| Central Front Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross-member (6.1.1 (c) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded flitch panel under wing |2.4.A.3| | 1 |
| Emissions not tested due to possible turbo failure |8.2.2.2 |e|| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Brake lever has insufficient reserve travel parking |1.1.2 |a|| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded jacking point |2.4.A.3| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Front Exhaust has a major leak of exhaust gases pipe broken (6.1.2 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor area under step (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor area under step (7.1.1 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut top mounting point |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength suspension bed mounting point |5.3.6 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced step area (7.1.1 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding center
axel (1.2.1 (f)) | 1 |
| Power steering pipe/hose excessively corroded on rack (2.1.5 (g) (i)) | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases centre pipe holed and clamps missing (6.1.2 (a)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side 3rd axle near side (1.4.1 (a)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Battery insecure |1.9.1| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front Exhaust has a major leak of exhaust gases AT JOINT |7.1.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| All direction indicators not working N/S indicator on permanently affecting all other indicators (4.4.1 (a) (ii)) | 1 |
| Power steering pipe|s| or hose|s| excessively corroded on rack |2.3.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded Chassis |2.4.A.3| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Emissions not tested major exhaust leak. (8.2.2.2 (e)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Front Exhaust has a major leak of exhaust gases pipe (6.1.2 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Centre Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Outer Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |