| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 27 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 19 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 18 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Registration plate lamp issues | 14 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 14 |
| Brake hose excessively deteriorated | 13 |
| Rear parking brake recording little or no effort | 12 |
| Brake pipe excessively corroded | 12 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 8 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 8 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Offside Steering rack gaiter split |2.2.D.2d| | 6 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 6 |
| Brakes imbalanced across an axle | 6 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 5 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 4 |
| Windscreen has damage | 4 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Registration plate issues | 3 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear brake binding | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 3 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 2 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Indicator switch faulty |1.4.A.1| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Rear brake application uneven | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Obligatory mirror missing |8.1.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Offside Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Fuel pipe leaking filler neck (6.1.3 (b) (i)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit battery insecure and terminals loose (4.13 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting rear sill area (6.2.2 (d) (i)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced unacceptable method of repair used on nearside sill (filler/fibreglass) (6.1.1 (c) (i)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Fuel hose leaking excessively or a risk of fire Fuel tank breather is leaking. (6.1.3 (b) (ii)) | 1 |
| Electrical wiring insecure and connectors likely to become disconnected battery terminal is insecure. (4.11 (a) (ii)) | 1 |
| Offside Rear Fuel hose leaking |7.2.3| | 1 |
| Offside Rear Subframe mounting prescribed area is fractured |2.4.A.3| | 1 |
| Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
| Offside Power steering ram|s| leaking from a failed seal |2.3.3b| | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Brake servo leaking |3.6.C.1c| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Offside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Windscreen washer not working | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Rear fog lamp not working |1.3.2b| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Inner Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front drive shaft coupling is insecure |2.5.C.1c| | 1 |
| Front brake application uneven | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Rear Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Brake pipe likely to become detached or damaged (1.1.11 (d) (ii)) | 1 |
| Offside Rear Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |