| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 45 |
| Windscreen wiper does not clear the windscreen effectively | 30 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 25 |
| Rear brake binding | 25 |
| Registration plate lamp issues | 24 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 21 |
| Parking brake: efficiency below requirements |3.7.B.7| | 18 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 13 |
| Brake pipe excessively corroded | 13 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Rear parking brake recording little or no effort | 10 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
| Brakes imbalanced across an axle | 9 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Offside Rear Stop lamp not working |1.2.1b| | 6 |
| Rear brake application uneven | 6 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Exhaust engine idle speed too high |7.3.A.2a| | 4 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Fuel pipe leaking |7.2.3| | 3 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Windscreen wiper blade insecure | 3 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Registration plate issues | 2 |
| Rear fog lamp tell-tale not working |4.9.1 |a| |ii|| | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Nearside Steering rack insecure |2.2.B.1a| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Indicator switch faulty |1.4.A.1| | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 2 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Fuel cap/sealing device missing |6.1.3 |b| |i|| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Centre Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Centre Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Windscreen has damage | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear wheel cylinder has restricted free movement |3.5.1k| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Lower Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Seat belt flexible stalk cable has broken strands |5.2.4b| | 1 |
| Stop lamp insecure |1.2.1a| | 1 |
| Exhaust has a major leak of exhaust gases back box. |7.1.2| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Offside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Body has a projection caused by damage |6.1.C.1| | 1 |
| Nearside Rear Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
| Nearside Lower Ball joint ball pin shank loose |2.2.B.1c| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Steering locking device insecure |2.2.C.1g| | 1 |
| Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Nearside Inner Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion wheel arch |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by damage bumper |6.1.C.1| | 1 |
| Suspension component mounting prescribed area is excessively corroded both sill /floor sections/rear sill ends/areas in door steps/off side rear strut mounting in boot |2.4.A.3| | 1 |
| Front brake application uneven | 1 |
| Indicator switch insecure |1.4.A.1| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded sill panel |2.4.A.3| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded sill panel |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded floor pan |2.4.A.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded top off outer sill |5.2.6| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded behind suspension turret in corner |2.4.A.3| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Spare wheel carrier insecure |6.4.2| | 1 |
| Nearside Front Upper Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |