Most common failures | No# failures |
---|
Brakes imbalanced across an axle | 11 |
Parking brake: efficiency below requirements |3.7.B.7| | 11 |
Service brake: efficiency below requirements |3.7.B.7| | 9 |
Registration plate lamp issues | 6 |
Brake pipe excessively corroded | 6 |
Headlamp aim out of alignment | 6 |
Windscreen wiper does not clear the windscreen effectively | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Front Exhaust system not adequately supported |7.1.1| | 3 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Front brake application uneven | 3 |
Rear brake application uneven | 3 |
Rear brake binding | 3 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Rear parking brake recording little or no effort | 3 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Indicator tell tale inoperative |1.4.A.2a| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Service brake: efficiency below requirements |3.7.C.1a| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Stop lamp not working |1.2.1b| | 2 |
Horn not working |1.6.2a| | 2 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Mechanical brake component has restricted free movement | 2 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Nearside Rear Braking system leaking |3.6.A.1| | 2 |
Offside Front Upper Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Upper Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Sub-frame attachment bracket/mounting cracked |2.4.G.1| | 1 |
Nearside Front Lower Sub-frame attachment bracket/mounting cracked |2.4.G.1| | 1 |
Offside Inner Front suspension locking device missing |2.5.A.4| | 1 |
Offside Outer Front suspension locking device ineffective |2.5.A.4| | 1 |
Offside Front suspension locking device missing |2.5.A.4| | 1 |
Nearside Front suspension locking device missing |2.5.A.4| | 1 |
Nearside Obligatory mirror missing |8.1.1| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Nearside Front Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
Offside Front Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear Parking brake mechanism/associated mounting prescribed area is excessively corroded bracket holding the cable cracked |3.1.9| | 1 |
Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Rear Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Nearside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Nearside Windscreen wiper blade missing |8.2.2| | 1 |
Offside Windscreen wiper blade missing |8.2.2| | 1 |
Steering locking device missing |2.2.C.1g| | 1 |
Registration plate issues | 1 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Front Braking system leaking |3.6.A.1| | 1 |
Front Brake performance not tested |3.7.A.1| | 1 |
Rear Brake performance not tested |3.7.A.1| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Offside Front wheel cylinder securing device loose |3.5.1j| | 1 |
Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Front suspension locking device missing |2.5.A.4| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Direction indicator not working |1.4.A.2c| | 1 |
Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Centre Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Front Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Front Subframe mounting prescribed area is inadequately repaired Outrigger at junction with chassis |2.4.A.3| | 1 |
Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Brake hose excessively deteriorated | 1 |
Offside Front rear brake grabbing severely |3.7.A.5b| | 1 |
An item not tested |Manual| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Brake performance not tested |3.7.A.1| | 1 |
Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Offside Inner Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Outer Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Outer Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Inner Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside front brake grabbing severely |3.7.A.2b| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Brake cable inappropriately repaired |3.5.1n| | 1 |
Centre Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Brake hose damaged | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Offside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Upper Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Fuel hose damaged |6.1.3 |c| |ii|| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |