| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 8 |
| Headlamp aim out of alignment | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Direction indicators not working |1.4.A.2c| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Front brake application uneven | 2 |
| Front Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Upper Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Nearside Front Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Offside Front Upper Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Offside Front Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Windscreen wiper blade missing |8.2.2| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Parking brake mechanism/associated mounting prescribed area is inadequately repaired |3.1.9| | 1 |
| Rear Exhaust has a major leak of exhaust gases on silencer |7.1.2| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| front brake recording little or no effort |3.7.B.5a| | 1 |
| Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Registration plate lamp issues | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Steering system lock to lock check stretches a brake pipe |2.2.D.2b| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Offside Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front wheel cylinder leaking |3.6.A.1| | 1 |
| Rear Lower wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Offside Rear Braking system leaking the single cylinder operating rear foot brakes on axle |3.6.A.1| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Nearside Rear Braking system leaking drum area |3.6.A.1| | 1 |
| Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by rear spring hanger (5.3.6 (a) (i)) | 1 |