| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 34 |
| Headlamp aim out of alignment | 31 |
| Brake pipe excessively corroded | 19 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Rear parking brake recording little or no effort | 6 |
| Offside Side repeater not working |1.4.A.2c| | 6 |
| Registration plate issues | 6 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 5 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Windscreen washer not working | 4 |
| Brakes imbalanced across an axle | 4 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Brake hose excessively deteriorated | 4 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Stop lamp remains on when the brakes are released | 3 |
| Rear brake binding | 3 |
| Brake performance not tested |3.7.A.1| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 2 |
| Fuel pipe leaking |7.2.3| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Centre Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear Tie bar/rod severely distorted |2.4.G.1| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Fuel pipe leaking Both front to rear |7.2.3| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake linkage has abnormal movement of levers indicating maladjustment |3.5.1f| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Lower Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Outer Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Outer Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Central Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Fuel system component insecure |7.2.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Fuel system component insecure |7.2.1| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake hose kinked |3.6.B.4b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Brake servo vacuum pipe excessively chafed |3.6.C.1b| | 1 |
| Front Anti-roll bar linkage has excessive play in a ball joint both |2.4.G.2| | 1 |
| Offside Front Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength under the wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Fuel pipe insecure pump (6.1.3 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Coil spring fractured or broken broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Offside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Exhaust system insecure hanger (6.1.2 (a)) | 1 |
| Headlamp levelling device cannot be operated from the drivers seat (4.1.5 (b)) | 1 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Oil leaking excessively from engine oil cooler hose (8.4.1 (a) (i)) | 1 |
| Nearside Front Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Brake performance unable to be tested brake pipe burst (1.2.1 (g)) | 1 |