| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 44 |
| Registration plate lamp issues | 19 |
| Rear brake binding | 13 |
| Brakes imbalanced across an axle | 11 |
| Service brake: efficiency below requirements |3.7.B.7| | 9 |
| Rear parking brake recording little or no effort | 9 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Horn not working |1.6.2a| | 8 |
| Nearside front brake binding |3.7.B.1| | 7 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside front brake binding |3.7.B.1| | 4 |
| Mechanical brake component has restricted free movement | 4 |
| Registration plate issues | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Stop lamp not working |1.2.1b| | 3 |
| Brake pedal spongy |3.3.B.1b| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Indicator tell tale inoperative |1.4.A.2a| | 3 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 3 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 3 |
| Windscreen washer not working | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Front brake application uneven | 3 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 3 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Windscreen wiper not working (3.4 (a)) | 2 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Rear Braking system leaking |3.6.A.1| | 2 |
| Offside Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Track rod end loose |2.2.B.1d| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Battery insecure |1.9.1| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Nearside Upper Front suspension locking device ineffective |2.5.A.4| | 1 |
| Offside Upper Front suspension locking device ineffective |2.5.A.4| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both front (4.1.2 (c)) | 1 |
| Nearside Rear Valve stem seriously misaligned Not fully fitted in rim (5.2.3 (j)) | 1 |
| Nearside Front Inner Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect kick up to right (4.1.2 (c)) | 1 |
| Fuel cap/sealing device missing seal missing (6.1.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Fuel system component leaking front carb dripping |7.2.3| | 1 |
| Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Outer Track rod end loose |2.2.B.1d| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Nearside Front Anti-roll bar pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Anti-roll bar pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Lower Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Nearside Front Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength spring cup (5.3.6 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded Tie-bar area |look in from front of vehicle| |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded Anti roll bar D-bush mount |2.4.A.3| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Brake pipe excessively corroded | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Brake hose excessively deteriorated | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Front Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside Drag link end loose |2.2.B.1d| | 1 |
| Offside Drag link end loose |2.2.B.1d| | 1 |
| Offside Front Brake master cylinder insecurely mounted |3.6.G.1a| | 1 |
| Offside Front Upper Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Front suspension locking device missing ball joint |2.5.A.4| | 1 |
| Offside Front Upper Front suspension locking device missing ball joint |2.5.A.4| | 1 |
| Steering locking device missing all 4 track rod ends |2.2.C.1g| | 1 |
| Braking system leaking brake pipe ends going into banjo bolt ends |3.6.A.1| | 1 |
| Rear Fuel hose insecure hose clip loose |7.2.1| | 1 |
| Driver`s door catch deteriorated so the door cannot be readily opened or closed |6.2.B.2| | 1 |
| Nearside Steering component mounting prescribed area is fractured chassis leg |2.1.2 |e| |i|| | 1 |
| Offside Steering component mounting prescribed area is fractured chassis leg |2.1.2 |e| |i|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Direction indicator incorrect colour both |1.4.A.2f| | 1 |
| Front Exhaust has a major leak of exhaust gases exhaust clamp missing |7.1.2| | 1 |
| Steering box insecure cover loose |2.2.B.1a| | 1 |
| Intermediate drop arm insecure castle nut missing split pin
|2.2.B.1a| | 1 |
| Offside Front Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Drag link end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Track rod end loose |2.2.B.1d| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Braking system leaking nearside front caliper / bleed nipple |3.6.A.1| | 1 |
| Nearside Rear Trailing arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Inner Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Shock absorber insecure |2.7.2b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Centre Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Shock absorber missing |2.7.1b| | 1 |
| Offside Rear Shock absorber missing |2.7.1b| | 1 |
| Nearside Front Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Front Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Front Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings next to anti roll bar mounting |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings next to anti roll bar mounting |6.1.B.2| | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |