| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 39 |
| Brake pipe excessively corroded | 19 |
| Headlamp aim out of alignment | 19 |
| Rear parking brake recording little or no effort | 18 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Registration plate lamp issues | 7 |
| Brake hose excessively deteriorated | 7 |
| Offside Steering rack gaiter split |2.2.D.2d| | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
| Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Registration plate issues | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Windscreen has damage | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Fuel hose leaking |7.2.3| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Brake hose has insufficient room to move | 2 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Fuel system component insecure |7.2.1| | 2 |
| Offside Rear Suspension arm severely distorted |2.4.G.1| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner sill area (5.3.6 (a) (i)) | 1 |
| Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Both sides inner sill area (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits 1577 (8.2.1.2 (b)) | 1 |
| Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake warning device not working correctly |3.3.D.3a| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| rear brake recording little or no effort both |3.7.B.5a| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings both sides at jacking points |6.1.B.2| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Rear Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Offside Rear Brake cable locking device insecure |3.5.1l| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Front Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Rear Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| An item not tested |Manual| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake hose damaged | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Macpherson strut fractured |2.4.G.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Rear brake binding | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Tie bar/rod severely distorted |2.4.G.1| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen too low |4.1.2 |a|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Rear Fuel hose leaking excessively or a risk of fire pipe to tank |6.1.3 |b| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Rear Subframe mounting prescribed area is severely distorted |2.4.A.3| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Rear Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Front Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Suspension arm severely distorted |2.4.G.1| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |