| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 95 |
| Registration plate lamp issues | 28 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 26 |
| Windscreen wiper does not clear the windscreen effectively | 24 |
| Windscreen washer not working | 20 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 19 |
| Front brake disc in such a condition that it is seriously weakened | 15 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 13 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 12 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 12 |
| Rear parking brake recording little or no effort | 11 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 10 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 8 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 8 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 7 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 6 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 6 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Rear Brake cable insecure | 6 |
| Registration plate issues | 6 |
| Brakes imbalanced across an axle | 6 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Rear Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 5 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 5 |
| Offside Front Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 5 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 5 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 5 |
| Rear brake binding | 4 |
| Nearside Front Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 4 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 4 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Horn not working (7.7 (a)) | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 4 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Front brake excessively fluctuating | 4 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 3 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 3 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 3 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Nearside Brake cable insecure |1.1.15 |c|| | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 2 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Windscreen has damage | 2 |
| Nearside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Headlamp insecure |4.1.1 |c|| | 2 |
| Rear Exhaust system insecure (6.1.2 (a)) | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Central Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Central Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Offside Headlamp aim not tested |4.1.2 |b|| | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Oil leaking continuously from engine posing a serious risk to road safety |8.4.1 |a| |ii|| | 2 |
| Offside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |