| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Registration plate lamp issues | 7 |
| Brake pipe excessively corroded | 5 |
| Brake hose excessively deteriorated | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Windscreen washer not working | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Brakes imbalanced across an axle | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Offside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Rear Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Radius arm insecure |2.4.G.1| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Exhaust shield missing where fitted as original equipment creating a risk of fire Manifold (6.1.3 (e)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Offside Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Offside Front Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Headlamp aim beam image obviously incorrect both chrome corroded |1.8.A.1b| | 1 |
| Nearside Front Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases ring missing at tailpipe |7.1.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded innerwing at |2.4.A.3| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner sill (6.1.1 (d) (i)) | 1 |
| Offside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner sill (6.1.1 (d) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner arch (6.1.1 (c) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp indicator |1.1.A.3f| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded step |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded outer step |5.2.6| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Headlamp aim not tested due to head lights not working (4.1.2 (b)) | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |