| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 10 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
| Offside Steering rack gaiter split |2.2.D.2d| | 3 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Brakes imbalanced across an axle | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Steering rack gaiter insecure split at end |2.2.D.2d| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Lower Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Registration plate issues | 1 |
| Registration plate lamp issues | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Rear brake application uneven | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturer`s specified limits |8.2.1.2 |b|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement `D` bush |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Brake reservoir fluid level decreases after several pedal applications |3.3.C.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Offside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Offside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |