| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 25 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 10 |
| Windscreen washer not working | 5 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 4 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 4 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Headlamp aim out of alignment | 3 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 2 |
| Nearside Front Macpherson strut pin or bush excessively worn Top leg mount (5.3.4 (a) (i)) | 2 |
| Brake performance unable to be tested (1.2.1 (g)) | 2 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Registration plate lamp issues | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Direction indicator incorrect colour both rear (4.4.3 (a)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Macpherson strut corroded and seriously weakened (5.3.3 (b) (i)) | 2 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Offside Front Headlamp levelling device inoperative (4.1.5 (a)) | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction Sun visor wont stay in the off screen position (3.1 (a) (ii)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Steering system excessively rough Top mount. (2.1.1 (a)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Battery insecure and likely to cause a short circuit battery terminals loose (4.13 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel pipe burst (1.2.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Valve stem seriously misaligned |4.1.D.1e| | 1 |
| Offside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases front flexi pipe broken and rear box deteriorated (6.1.2 (a)) | 1 |
| Seat belt buckle not functioning as intended centre (7.1.2 (d)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested brake pipe failure (1.2.1 (g)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn Rear Bush (5.3.4 (a) (i)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Nearside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Side repeater light intensity significantly reduced (4.4.3 (a)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Inner Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Fuel tank leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill corroded/ holed (7.1.1 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Rear Direction indicator incorrect colour nearside and offside (4.4.3 (a)) | 1 |
| Nearside Rear Body component damaged and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt clip insecure (6.1.7 (g) (ii)) | 1 |
| Exhaust system insecure back box (6.1.2 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting corroded and seriously weakened retaining nut & washer (5.3.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting corroded and seriously weakened retaining washer / nut (5.3.3 (b) (i)) | 1 |
| Offside Rear Brake drum back plate insecure corroded holed (1.1.14 (d)) | 1 |
| Nearside Front Macpherson strut corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Rear Fuel tank leaking |7.2.3| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Inner Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Inner Trailing arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt track rod end |2.4.G.2| | 1 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Registration plate issues | 1 |
| Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Steering arm deformed Play (2.1.3 (c) (i)) | 1 |
| Nearside Front Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Offside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Emissions not tested due to misfire (8.2.1.2 (d)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Anti-roll bar corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Lower Anti-roll bar insecure and impairing directional stability Through lower arm (5.3.3 (a) (ii)) | 1 |