| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 45 |
| Windscreen wiper does not clear the windscreen effectively | 36 |
| Registration plate lamp issues | 18 |
| Headlamp aim out of alignment | 16 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Brakes imbalanced across an axle | 5 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
| Central Exhaust system insecure (6.1.2 (a)) | 3 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Fuel tank leaking (6.1.3 (b) (i)) | 2 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Rear Brake pipe leaking on a hydraulic braking system front to rear at rear (1.1.11 (b) (ii)) | 1 |
| Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (rear )both sides front suspension mounts holed (6.1.1 (c) (i)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Offside Rear Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Windscreen has damage | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn rear to lower arm (5.3.4 (a) (i)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Rear Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Brake pipe leaking on a hydraulic braking system pipe running to offside rear (1.1.11 (b) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Holed at rear sub frame mounting (6.1.1 (c) (i)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Front Service brake excessively fluctuating brake judder at front |1.2.1 |e|| | 1 |
| Bumper damaged and likely to cause injury when grazed or contacted front bumper damaged with sharp edges |6.1.4 |a| |i|| | 1 |
| Exhaust system insecure center exhaust bracket loose |6.1.2 |a|| | 1 |
| Windscreen wiper not operating automatically when switched on no self parking |8.2.1b| | 1 |
| Emissions not tested fuel leak /exhaust leak (8.2.1.2 (d)) | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively damaged significantly reducing structural strength sill at jacking point (5.3.6 (a) (i)) | 1 |
| Fuel pipe leaking filler pipe at tank (6.1.3 (b) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength trailing arm mounting point at chassis leg (5.3.6 (a) (i)) | 1 |
| Anti-roll bar pin or bush excessively worn both front (5.3.4 (a) (i)) | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting mid way up the chassis (6.2.2 (d) (i)) | 1 |
| Offside Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting mid way up the chassis (6.2.2 (d) (i)) | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Rear wishbone bush. (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn Rear wishbone bush. (5.3.4 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Fuel hose leaking filler neck pipe (6.1.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Rear Exhaust silencer likely to become detached |8.1.1 |b| |ii|| | 1 |
| Rear Service brake excessively fluctuating both sides |1.2.1 |e|| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust system insecure back box (6.1.2 (a)) | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Rear Exhaust system insecure mtg broken (6.1.2 (a)) | 1 |
| Fuel tank insecure |6.1.3 |a| |i|| | 1 |
| Rear Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Nearside Rear Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Trailer electrical socket |13 pin| not functioning at all |4.10 |c| |ii|| | 1 |
| Fluid leak harmful to the environment or a risk to other road users coolant |8.4.1 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt arm (5.3.4 (b) (ii)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Exhaust system not adequately supported rear |7.1.1| | 1 |
| Front Anti-roll bar linkage pin or bush excessively worn both sides d bushes |5.3.4 |a| |i|| | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak back box |8.2.1.1 |b|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill section (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis & inner sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis & inner sill (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength trailing arm mount (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened trailing arm (5.3.3 (b) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front Drivers seat with a defective structure (6.2.5 (a) (i)) | 1 |
| Nearside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Emissions unable to be completed leak of exhaust gasses (8.2.1.2 (d)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear pin/bush. (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear pin/bush. (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |