| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 111 |
| Brake pipe excessively corroded | 48 |
| Headlamp aim out of alignment | 42 |
| Registration plate lamp issues | 28 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 20 |
| Registration plate issues | 18 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 18 |
| Brakes imbalanced across an axle | 18 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 17 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 15 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 12 |
| Brake hose excessively deteriorated | 12 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 11 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 11 |
| Offside Front coil spring broken |2.4.C.1a| | 10 |
| Nearside front brake binding |3.7.B.1| | 9 |
| Offside front brake binding |3.7.B.1| | 9 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 9 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 8 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 8 |
| Front brake disc in such a condition that it is seriously weakened | 8 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 6 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 6 |
| Rear Exhaust system not adequately supported |7.1.1| | 6 |
| Offside Front Position lamp not working |4.2.1 |a|| | 6 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 5 |
| Mechanical brake component has restricted free movement | 5 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 4 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 4 |
| Nearside Front coil spring broken |2.4.C.1a| | 4 |
| Nearside Rear Shock absorbers has a serious fluid leak | 4 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 4 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 3 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 3 |
| Offside Rear coil spring broken |2.4.C.1a| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 3 |
| Windscreen wiper blade insecure | 2 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Power steering component leaking steering rack (2.1.5 (a)) | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Offside Front Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Rear brake application uneven | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Front Hydraulic fluid leaking excessively (8.4.1 (a) (i)) | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |