| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 30 |
| Registration plate lamp issues | 25 |
| Offside Rear fog lamp not working |1.3.2b| | 16 |
| Brake pipe excessively corroded | 15 |
| Brake hose excessively deteriorated | 13 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 8 |
| Rear brake application uneven | 7 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Brakes imbalanced across an axle | 6 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 5 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear brake binding | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Windscreen has damage | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Registration plate issues | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Centre Steering pivot point has excessive play |2.2.B.1g| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Centre Steering arm has relative movement at its fixings |2.2.B.1h| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Windscreen wiper blade insecure | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Brake hose damaged | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Centre Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Front Side repeater missing |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded bulkhead |1.1.21 |e| |i|| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Front Wheel insecure |4.2.A.1c| | 1 |
| Rear Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside Front coil spring corroded so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
| Offside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
| Centre Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is severely distorted |2.4.A.3| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Leaf spring shackle bracket cracked |2.4.B.6b| | 1 |
| Nearside Rear Leaf spring shackle bracket cracked |2.4.B.6b| | 1 |
| Rear rear brakes release unevenly |3.7.B.4| | 1 |
| Inner Steering rack gaiter split |2.2.D.2d| | 1 |
| Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Drive shaft uj which forms part of the suspension has a loose flange bolt |2.4.G.4c| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Rear Other passenger door catch insecure hatch |6.2.3 |c| |ii|| | 1 |
| Outer Front Brake performance not tested |3.7.A.1| | 1 |
| Outer Rear Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Steering pivot point has excessive play connected to rack arms from the steering rack |2.2.B.1g| | 1 |
| Steering rack gaiter split outer rack gaitor split |2.2.D.2d| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings near steering rack |6.1.B.2| | 1 |
| Front Exhaust has a major leak of exhaust gases front pipe to manifold join |7.1.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Suspension spring mounting prescribed area is excessively corroded o/s & n/s |2.4.A.3| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement rear springs o/s & n/s front bushes |2.4.B.2| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded floor |2.2.C.1h| | 1 |
| Exhaust has a major leak of exhaust gases @manifold |7.1.2| | 1 |
| Centre Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush front |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush front |2.4.B.2| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Offside Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering arm damaged and unserviceable |2.2.C.1d| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering rack gaiter split |2.2.D.2d| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Rear Lower Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear reflector more than 50% obscured |1.5.1b| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Obligatory mirror missing |8.1.1| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Leaf spring anchor pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Intermediate drop arm insecure excessive play in bush /pin (2.1.3 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Windscreen wiper not working blown fuse found, replaced (3.4 (a)) | 1 |
| Nearside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Front Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Hinged tailboard cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Emissions not tested exhaust leak (8.2.1.2 (d)) | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Drivers seat belt |7.1.1 |a| |i|| | 1 |
| Offside Front Outer Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill |6.2.2 |d| |i|| | 1 |
| Offside Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill |6.2.2 |d| |i|| | 1 |
| Front Drag link end ball joint has excessive play Center linkage |2.1.3 |b| |i|| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |