| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Brake pipe excessively corroded | 12 |
| Headlamp aim out of alignment | 10 |
| Registration plate lamp issues | 9 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Registration plate issues | 7 |
| Brakes imbalanced across an axle | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Power steering inoperative (2.1.5 (c) (i)) | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Windscreen washer not working | 1 |
| Offside Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Front Lower Steering rack insecure |2.2.B.1a| | 1 |
| Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Rear brake application uneven | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Brake reservoir fluid level decreases after several pedal applications |3.3.C.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front coil spring cracked |2.4.C.1a| | 1 |
| Offside Front Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |