| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 41 |
| Headlamp aim out of alignment | 26 |
| Windscreen wiper does not clear the windscreen effectively | 24 |
| Brake pipe excessively corroded | 21 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 19 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 18 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 15 |
| Registration plate issues | 13 |
| Offside Rear fog lamp not working |1.3.2b| | 12 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 12 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 12 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 8 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
| Centre Steering pivot point has excessive play |2.2.B.1g| | 7 |
| Brakes imbalanced across an axle | 7 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Rear parking brake recording little or no effort | 6 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 6 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside front brake binding |3.7.B.1| | 5 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Windscreen has damage | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Offside front brake binding |3.7.B.1| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 4 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Brake hose excessively deteriorated | 4 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Mechanical brake component has restricted free movement | 3 |
| Exhaust engine idle speed too high |7.3.A.2a| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Steering column top bearing excessively worn |2.1.2c| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 3 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Headlamp aim not tested |1.8.A.1c| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front An item not tested |Manual| | 2 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Outer Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Inner Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 1 |
| Front Anti-roll bar synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| brake drum in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front All position lamps not in good working order |function impaired| |1.1.A.2a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded chassis x2 place`s |2.4.A.3| | 1 |
| Nearside Outer Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Nearside coil spring fractured |2.4.C.1a| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Sub-frame attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Offside Front Sub-frame attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Outer Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Outer Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Oil leaking excessively from engine Very bad oil leak (8.4.1 (a) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn Front bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Sub-frame pin or bush excessively worn Front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired Fibreglass (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired Fibreglass (5.3.6 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Brake pipe likely to become detached or damaged (1.1.11 (d) (ii)) | 1 |
| Offside Rear Brake pipe likely to become detached or damaged (1.1.11 (d) (ii)) | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Horn not a constant note |1.7.1e| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Front Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Rear Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Front Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Intermediate drop arm damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Direction indicators not working on hazards |1.4.A.2c| | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded spring mounting area |2.4.A.3| | 1 |
| Nearside Front Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Rear brake application uneven | 1 |
| Offside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Outer Headlamp not working on main beam |1.7.5a| | 1 |