| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 30 |
| Brake pipe excessively corroded | 14 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 13 |
| Headlamp aim out of alignment | 12 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 10 |
| Registration plate lamp issues | 10 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 8 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 8 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 7 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Offside Rear Inner Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Rear Outer Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 4 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 4 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 4 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Rear Outer Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 2 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 2 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Offside Rear Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Rear Position lamp not working tail lamp in tail gate (4.2.1 (a) (ii)) | 1 |
| Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Electrical wiring insecure ABS wiring inscure |1.9.2a| | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Headlamp levelling device inoperative Level warning light on and aim low (4.1.5 (a)) | 1 |
| Headlamp light intensity severely reduced Both headlight lenses badly faded (4.1.4 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases CORRODED, BROKEN AND BLOWING.. (6.1.2 (a)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect lense deteriorated (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect lense deteriorated (4.1.2 (c)) | 1 |
| Central Rear Upper Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii)) | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Rear Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Central Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety Engine Oil (8.4.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt Upper and Lower (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt Upper and Lower (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D Bush (5.3.4 (a) (i)) | 1 |
| Rear Anti-roll bar corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Headlamp light intensity severely reduced both (4.1.4 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Front Position lamp not working NS and OS (4.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Bonnet primary retaining device excessively deteriorated |3.1 |c|| | 1 |
| Oil leaking excessively from transmission Transmission oil cooler pipe leaking (8.4.1 (a) (i)) | 1 |
| Front Position lamp not working Both (4.2.1 (a) (ii)) | 1 |
| Nearside Side repeater light intensity significantly reduced (4.4.3 (a)) | 1 |
| Offside Rear Seat belt damaged (7.1.2 (b) (i)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Electronic braking system warning device indicates a fault (1.7 (b)) | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Windscreen washer not working | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii)) | 1 |
| Offside Front Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Body component damaged and likely to cause injury mirror (6.2.1 (a) (i)) | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Central Front Exhaust shield missing where fitted as original equipment creating a risk of fire (6.1.3 (e)) | 1 |
| Front Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Emissions unable to be completed Major exhaust bleak (8.2.1.2 (d)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Steering linkage ball joint has excessive play on rack (2.1.3 (b) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction secondary air pump fault (8.2.1.2 (h)) | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Nearside Rear Headlamp levelling device inoperative lever snapped (4.1.5 (a)) | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Hydraulic brake calliper insecurely mounted and braking performance affected (1.1.16 (c) (ii)) | 1 |
| Offside Rear Hydraulic brake calliper insecurely mounted (1.1.16 (c) (i)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working light cluster damaged |1.2.1b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| All position lamps light intensity significantly reduced no side lights working (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Outer Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn bottom arm rear bush worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn wishbone rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Emissions unable to be completed due to leak (8.2.1.2 (d)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Front Lower Suspension arm pin or bush excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Bottom arm, rear bush. (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Bottom arm, rear bush. (5.3.4 (a) (i)) | 1 |
| Nearside Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Nearside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Rear Seat belt stitching badly frayed |5.2.2b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Statutory seat belt missing centre |5.1.1| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Side repeater missing both (4.4.1 (a) (ii)) | 1 |
| Registration plate issues | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
| Brake performance not tested not tested due to broken spring (1.2.1 (g)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended rear foglamp operating with n/s/r indcator. |1.9.4| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |