| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 61 |
| Windscreen wiper does not clear the windscreen effectively | 51 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 24 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 20 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 15 |
| Windscreen washer not working | 13 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 11 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 10 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 10 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 9 |
| Registration plate lamp issues | 9 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 6 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 5 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 4 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Rear Headlamp levelling device inoperative (4.1.5 (a)) | 3 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |
| Brake pipe excessively corroded | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Registration plate issues | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Exhaust has a major leak of exhaust gases tailpipe join (6.1.2 (a)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Central Emissions unable to be completed leaking from exhaust joint (8.2.2.2 (e)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases centre pipe flange (6.1.2 (a)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Side repeater missing both sides |1.4.A.2b| | 1 |
| Rear fog lamp missing no switch or telltail either |1.3.2a| | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Body has a sharp edge caused by damage light cluster |6.1.C.1| | 1 |
| Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Anti-roll bar linkage ball joint excessively worn both fronts (5.3.4 (a) (i)) | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect No pattern. (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect No pattern. (4.1.2 (c)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt rubber split/perished & ball joint worn |5.3.4 |b| |ii|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |4.10 |c| |i|| | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement rear |2.4.G.2| | 1 |
| Offside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak both flange joints (8.2.1.1 (b)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak centre at joint (8.2.1.1 (b)) | 1 |
| Nearside Rear Exhaust emissions likely to be affected by an induction leak (8.2.1.1 (b)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases central-rear (6.1.2 (a)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Body panel likely to become detached sill panel nearside (6.2.1 (a) (ii)) | 1 |
| Body panel insecure rear bumper offside corner (6.2.1 (a) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split (6.1.7 (g) (ii)) | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush rear bush |2.4.G.2| | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction (3.1 (a) (ii)) | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn loose (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt clip missing (6.1.7 (g) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Anti-roll bar linkage insecure both fronts |2.4.G.1| | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect no pattern (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect no pattern (4.1.2 (c)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Service brake excessively binding Both side (1.2.1 (f)) | 1 |
| Offside Front Anti-roll bar linkage insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface covered in masking tape and paint |4.8.1 |a| |ii|| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases Nearside centre to rear exhaust flange excessively corroded & leaking (6.1.2 (a)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases Offside centre to rear exhaust flange excessively corroded & leaking (6.1.2 (a)) | 1 |
| Power steering malfunctioning Steering turning to offside with very little effort indicating internal failure of steering rack. (2.1.5 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Power steering malfunctioning steering operation is not functioning as it should (2.1.5 (a)) | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn DROP LINK (5.3.4 (a) (i)) | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Offside Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Offside Rear fog lamp lens defective such that emitted light is adversely affected (4.5.1 (b) (ii)) | 1 |
| Side repeater missing both |1.4.A.2b| | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp incorrect colour bulb is yellow |1.7.5b| | 1 |
| Windscreen has damage | 1 |
| Central Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Central Rear Seat belt flexible stalk damaged stalk missing (7.1.2 (b) (i)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Rear Brake disc significantly and obviously worn both rear (1.1.14 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn bottom arm, rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush bonding failed |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Steering rack casing fractured (2.1.2 (d) (i)) | 1 |
| Central Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Brake disc significantly and obviously worn all 4 discs (1.1.14 (a) (i)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment No Reserve Travel (1.1.6 (c)) | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Front Anti-roll bar pin or bush excessively worn both front roll bar D bushes are worn (5.3.4 (a) (i)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn both rear roll bar D bushes are worn (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Anti-roll bar ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Inner Drive shaft likely to become detached (6.1.7 (a) (ii)) | 1 |
| Nearside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |