| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 14 |
| Headlamp aim out of alignment | 12 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 11 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Rear parking brake recording little or no effort | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Registration plate lamp issues | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Rear Exhaust system not adequately supported |7.1.1| | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Rear brake binding | 3 |
| Emissions not tested |7.0| | 3 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Registration plate issues | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Bonnet cannot be secured in the closed position |8.4.1| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Nearside Front Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Nearside Rear Fluid suspension unit totally deflated |2.4.D.1a| | 1 |
| Nearside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm insecure |2.4.G.1| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Passenger`s seat insecure |6.2.A.1| | 1 |
| Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Nearside Front Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Anti-roll bar locating pin insecure |2.4.G.3a| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Windscreen has damage | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| An item not tested |Manual| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Centre Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Brakes imbalanced across an axle | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Front suspension has excessive play in a upper wishbone bearing |2.5.B.1a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |