Most common failures | No# failures |
---|
Registration plate lamp issues | 51 |
Windscreen wiper does not clear the windscreen effectively | 47 |
Brake pipe excessively corroded | 45 |
Headlamp aim out of alignment | 32 |
Horn not working |1.6.2a| | 21 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 11 |
Registration plate issues | 11 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 10 |
Brakes imbalanced across an axle | 9 |
Offside Headlamp not working on dipped beam |1.7.5a| | 9 |
Front brake disc in such a condition that it is seriously weakened | 9 |
Nearside Stop lamp not working |1.2.1b| | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Horn not working (7.7 (a) (ii)) | 5 |
Offside Front coil spring broken |2.4.C.1a| | 5 |
Parking brake: efficiency below requirements |3.7.B.7| | 5 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 5 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 4 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
Rear parking brake recording little or no effort | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Offside Rear Stop lamp not working |1.2.1b| | 4 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 3 |
Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 3 |
Offside Front Direction indicators incorrect colour |1.4.A.2f| | 3 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 3 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 3 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 3 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 3 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
Windscreen has damage | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 2 |
Front brake application uneven | 2 |
Front brake excessively fluctuating | 2 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Rear Road wheel cracked |4.2.A.1a| | 2 |
Rear brake binding | 2 |
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Horn not working (7.7 (a)) | 2 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
Fuel cap/sealing device sealing washer torn |7.2.4c| | 2 |
Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Rear Direction indicator incorrect colour both |1.4.A.2f| | 2 |
Offside Side repeater incorrect colour |1.4.A.2f| | 2 |
Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
Nearside Side repeater incorrect colour (4.4.3 (a)) | 2 |
Offside Side repeater incorrect colour (4.4.3 (a)) | 2 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Front Anti-roll bar linkage insecurely attached Incorrectly fitted (5.3.3 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage insecurely attached incorrectly fitted (5.3.3 (a) (i)) | 1 |
Rear Direction indicator incorrect colour both (4.4.3 (a)) | 1 |
Nearside Rear Anti-lock braking system component excessively damaged pick ring |3.4.2| | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Offside Rear Road wheel fractured inner rim (5.2.2 (a)) | 1 |
brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Rear Road wheel cracked |4.2.A.1a| | 1 |
Offside Rear Anti-lock braking system component excessively damaged ABS ring snapped |3.4.2| | 1 |
Nearside Front All direction indicators incorrect colour (4.4.3 (a)) | 1 |
Offside Front All direction indicators incorrect colour (4.4.3 (a)) | 1 |
Nearside Front Brake drum significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Offside Front Brake drum significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
Nearside Front coil spring broken |2.4.C.1a| | 1 |
Offside Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Centre Rear Stop lamp not working |1.2.1b| | 1 |
Horn sounds harsh or grating |1.6.2e| | 1 |
Offside Rear Anti-lock braking system component excessively damaged abs reluctor ring |3.4.2| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Windscreen wiper missing (3.4 (a)) | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Brake hose excessively twisted |1.1.12 |b| |ii|| | 1 |
Brake hose damaged | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Front Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
Offside Front Suspension arm attachment bracket/mounting corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Nearside Front Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
Brake hose excessively deteriorated | 1 |
Nearside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Nearside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
Offside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
Offside Front Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Brake fluid warning lamp inoperative |3.6.G.2| | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front coil spring fractured |2.4.C.1a| | 1 |
Offside Front Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Offside Rear Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Offside Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Emissions not tested |7.3.A.1| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Offside Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Rear brake application uneven | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Position lamp switch does not operate in accordance with the requirements |4.2.2 |a|| | 1 |
Nearside Front position lamp|s| not working came on when tapped. |1.1.A.3b| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Direction indicator incorrect colour Off side and near side front |1.4.A.2f| | 1 |
Headlamp not working on dipped beam Off side |1.7.5a| | 1 |
Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
Nearside Front Seat belt damaged (7.1.2 (b) (i)) | 1 |
Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.2.C.1c) | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a) | 1 |
Nearside Front coil spring broken (2.4.C.1a) | 1 |
Steering column top bearing excessively worn (2.1.2c) | 1 |
Offside Rear Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Side repeater incorrect colour (1.4.A.2f) | 1 |
Nearside Headlamp not working on dipped beam (1.7.5a) | 1 |
Supplementary Restraint System warning lamp indicates a fault (5.4.2) | 1 |
Offside Stop lamp not working (1.2.1b) | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Offside Rear Road wheel fractured |5.2.2 |a|| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Rear Inner Road wheel cracked |4.2.A.1a| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Rear All direction indicators incorrect colour |4.4.3 |a|| | 1 |
Offside Front All direction indicators incorrect colour |4.4.3 |a|| | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
All direction indicators incorrect colour (4.4.3 (a)) | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Headlamp aim not tested |4.1.2 |b|| | 1 |
Nearside Front Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Rear Body panel damaged and likely to cause injury wing damaged/part missing |6.2.1 |a| |i|| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
Front engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Offside Front Coil spring not correctly located |2.4.C.2| | 1 |
Offside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Headlamp not working on main beam both |1.7.5a| | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
Nearside Front Suspension arm corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |