| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 26 |
| Windscreen wiper does not clear the windscreen effectively | 22 |
| Registration plate lamp issues | 20 |
| Brake pipe excessively corroded | 15 |
| Front brake disc in such a condition that it is seriously weakened | 10 |
| Registration plate issues | 6 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 5 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 5 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Horn not working (7.7 (a) (ii)) | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Anti-lock braking system component excessively damaged |3.4.2| | 2 |
| Offside Rear Anti-lock braking system component excessively damaged |3.4.2| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Emissions not tested |7.3.A.1| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Rear engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 2 |
| Brake hose excessively deteriorated | 2 |
| Horn not working (7.7 (a)) | 2 |
| Nearside Front Inner Brake lining(s) incorrectly mounted (1.1.13 (c)) | 1 |
| Offside Front Lower Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Upper Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Upper Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Emissions not tested aborted @ .7 lambda, 500hcs & 8.0c/o (8.2.1.2 (d)) | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Road wheel distorted |4.2.A.1a| | 1 |
| Offside Front Road wheel distorted |4.2.A.1a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Front brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Steering wheel rim loose |2.2.1 |c| |i|| | 1 |
| Offside Rear Direction indicator has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety timing cover suspect worn timing chain ? |8.4.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working side light |4.2.1 |a|| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Dipswitch does not operate immediately when selected on dipped beam (4.1.3 (b)) | 1 |
| Offside Front coil spring broken (2.4.C.1a) | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment (2.5.A.1c) | 1 |
| Fuel system component leaking evap tank damaged (6.1.3 (b) (i)) | 1 |
| Offside Headlamp aim beam image obviously incorrect (1.8.A.1b) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side loww effort (1.4.1 (a)) | 1 |
| Nearside Rear Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Horn not working pulled off connections and refit. |1.6.2a| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Windscreen washer not working | 1 |
| Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Nearside Lower Seat belt installation anchorage insecure |10.1 |d|| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Exhaust system not adequately supported loose and touching suspension |7.1.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Rear brake binding | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |