| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 7 |
| Brakes imbalanced across an axle | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear parking brake recording little or no effort | 4 |
| Brake pipe excessively corroded | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Steering column top bearing excessively worn |2.1.2c| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear brake binding | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Registration plate lamp issues | 2 |
| Steering wheel locking device insecure |2.1.6| | 1 |
| Offside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front brake application uneven | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Inner Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |