| Most common failures | No# failures |
|---|
| Brake hose excessively deteriorated | 16 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Rear brake binding | 7 |
| Registration plate issues | 7 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 5 |
| Registration plate lamp issues | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Brake pipe excessively corroded | 3 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Windscreen has damage | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Brake hose damaged | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings inner and outer sill |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front Brake pipe likely to become detached or damaged (1.1.11 (d) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front tie bar mounting (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Brake cable locking device missing |3.5.1l| | 1 |
| Offside Front Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Front Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Front Tie bar/rod insecure |2.4.G.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear brake application uneven | 1 |
| Rear Brake valve leaking |3.6.A.1| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Upper Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |