| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 44 |
| Headlamp aim out of alignment | 33 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 18 |
| Brakes imbalanced across an axle | 17 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 16 |
| Registration plate lamp issues | 15 |
| Rear parking brake recording little or no effort | 15 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Brake hose excessively deteriorated | 12 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 12 |
| Service brake: efficiency below requirements |3.7.B.7| | 11 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 11 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 10 |
| Registration plate issues | 10 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 9 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 9 |
| Rear brake binding | 9 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 8 |
| Rear brake application uneven | 8 |
| Horn not working |1.6.2a| | 8 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Rear Exhaust system not adequately supported |7.1.1| | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Exhaust system not adequately supported |7.1.1| | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Rear Mechanical brake component has restricted free movement | 4 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 4 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 4 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Centre Exhaust mounting missing |7.1.1b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 3 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Fuel hose leaking |7.2.3| | 2 |
| Rear Exhaust mounting missing |7.1.1b| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Front brake application uneven | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 2 |
| Nearside Front Headlamp insecure |1.7.3| | 2 |
| Offside Front coil spring fractured |2.4.C.1a| | 2 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 2 |
| Parking brake: efficiency below requirements |3.7.D.4| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Obligatory mirror insecure |8.1.1| | 2 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Exhaust engine idle speed too high |7.3.A.2a| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Central Front Seat belt insecurely fixed to the vehicles structure |buckle| |5.2.1a| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Centre Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Inner Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen has damage | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Hazard warning lamps operated by more than one switch |1.4.B.1c| | 1 |
| Nearside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
| Nearside Front Macpherson strut attachment bracket/mounting likely to become detached hub to shock bolts lose (5.3.3 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Body panel insecure wing (6.2.1 (a) (i)) | 1 |
| Nearside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch hole within 30cm of seat belt anchoring point (6.2.2 (d) (i)) | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Centre Fuel hose leaking |7.2.3| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Brake load sensing valve has been removed and was fitted as standard |3.6.E.2| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is severely distorted |5.2.6| | 1 |
| Offside Inner Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
| Nearside Front coil spring corroded so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
| Offside Front coil spring worn so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Lower Front suspension has excessive play in an outer ball joint |2.5.B.2a| | 1 |
| Centre Front Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Direction indicator missing |1.4.A.2b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Inner Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Lower Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Rear position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Front suspension has a loose unit in the upper support bearing assembly |2.5.B.3b| | 1 |
| Offside Front Front suspension has a loose unit in the upper support bearing assembly |2.5.B.3b| | 1 |
| Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Outer Front drive shaft coupling flexible rubber or fabric coupling insecure |2.5.C.1e| | 1 |
| Offside Outer Front drive shaft coupling flexible rubber or fabric coupling insecure |2.5.C.1e| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Tie bar/rod attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Nearside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front passenger seat insecure |6.2.3| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |