| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 28 |
| Windscreen wiper does not clear the windscreen effectively | 25 |
| Registration plate lamp issues | 19 |
| Nearside Rear Shock absorbers has a serious fluid leak | 14 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 11 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 11 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 8 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 6 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 6 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Windscreen washer not working | 4 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Brakes imbalanced across an axle | 4 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Registration plate issues | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Front Windscreen wiper not working (3.4 (a)) | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Rear Reversing lamp inoperative |4.6.1 |a|| | 1 |
| Front brake application uneven | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Obligatory mirror insecure |8.1.1| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Brake disc significantly and obviously worn pitted |1.1.14 |a| |i|| | 1 |
| Offside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Front Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Central Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bearing bolts missing out of suspension arm |2.4.G.2| | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Drivers airbag obviously inoperative (7.1.5 (c)) | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Front Seat belt flexible stalk damaged (7.1.2 (b) (i)) | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Offside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect Damaged (4.1.2 (c)) | 1 |
| Central Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake lever has restricted free movement handbrake (1.1.15 (e)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Upper Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Nearside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Front Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak section,small silencer seam blowing (8.2.1.1 (b)) | 1 |
| Central Rear Exhaust has a major leak of exhaust gases box (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Exhaust emissions likely to be affected by an exhaust leak centre box leaking, (8.2.1.1 (b)) | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Nearside Front Seat belt not functioning as intended snagging on the B pillar trim (7.1.2 (c)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Fuel cap/sealing device component leaking (6.1.3 (b) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front Brake disc significantly and obviously worn both sides. (1.1.14 (a) (i)) | 1 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases centre box (6.1.2 (a)) | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Central Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Exhaust has a major leak of exhaust gases centre box (6.1.2 (a)) | 1 |
| Emissions unable to be completed exhaust leaking (8.2.1.2 (d)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Central Front Exhaust emissions likely to be affected by an exhaust leak First silencer holed possibly affecting emissions. (8.2.1.1 (b)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Exhaust has a major leak of exhaust gases middle box (6.1.2 (a)) | 1 |
| Offside Rear Outer Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect bulb not fitted correctly (4.1.2 (c)) | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Headlamp reflector seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear Anti-roll bar linkage ball joint excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Front Suspension arm pin or bush excessively worn Lower rear bush both sides (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn lower rear inner bush (5.3.4 (a) (i)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both sides (4.1.2 (c)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Windscreen wiper not working (3.4 (a)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |