| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 33 |
| Parking brake: efficiency below requirements |3.7.B.7| | 28 |
| Registration plate lamp issues | 21 |
| Rear parking brake recording little or no effort | 19 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 15 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 14 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 14 |
| Horn not working |1.6.2a| | 13 |
| Brake hose excessively deteriorated | 13 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 11 |
| Brakes imbalanced across an axle | 11 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 8 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Registration plate issues | 6 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear brake application uneven | 5 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 5 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Brake hose has insufficient room to move | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear brake binding | 3 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 3 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Battery insecure |1.9.1| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Brake pipe excessively corroded | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Front Coil spring not correctly located |2.4.C.2| | 2 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Indicator tell tale inoperative |1.4.A.2a| | 2 |
| Rear Exhaust mounting missing |7.1.1b| | 2 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Rear Coil spring not correctly located |2.4.C.2| | 2 |
| Offside Front brake caliper leaking |3.6.A.1| | 2 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Rear All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Windscreen washer not working | 1 |
| Brake hose damaged | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded Front |2.4.A.3| | 1 |
| Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded shocker mount in boot |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner wheel arch/sill end |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded boot floor area |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded boot floor area / inner arch |2.4.A.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Nearside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Suspension has inadequate clearance with the chassis |2.4.A.1a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Brake clevis joint inappropriately repaired |3.5.1n| | 1 |
| Offside Rear Brake clevis joint inappropriately repaired |3.5.1n| | 1 |
| Nearside Rear Mechanical brake component securing device loose |3.5.1i| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Centre Upper Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Lower Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Rear Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded Sill |5.2.6| | 1 |
| Offside Front Inner Suspension component mounting prescribed area is excessively corroded Wheel arch |2.4.A.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Jacking point (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Jacking point as marked (6.2.2 (d) (i)) | 1 |
| front brake recording little or no effort |3.7.B.5a| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front passenger seat insecure |6.2.3| | 1 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Windscreen wiper blade missing |8.2.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Front Exhaust has a major leak of exhaust gases pipe split |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer blowing and pipe split |7.1.2| | 1 |
| Centre Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded Flitch chassis turret and Inner mudgaurd very corroded and broken |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded Inner mudgaurd |2.4.A.3| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Centre Stop lamp insecure |1.2.1a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel hose excessively chafed |7.2.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Offside Front Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings o/s/f floor to sill holed at jacking point. |6.1.B.2| | 1 |
| Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |