| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 56 |
| Rear parking brake recording little or no effort | 27 |
| Registration plate lamp issues | 17 |
| Brake pipe excessively corroded | 17 |
| Headlamp aim out of alignment | 16 |
| Anti-lock braking system warning lamp indicates an ABS fault | 13 |
| Parking brake lever has no reserve travel |3.1.6b| | 13 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 12 |
| Service brake: efficiency below requirements |3.7.B.7| | 10 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 9 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 9 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 9 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 8 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Emissions not tested |7.0| | 6 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
| Brakes imbalanced across an axle | 5 |
| Registration plate issues | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear brake binding | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 2 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 2 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Bonnet retaining device ineffective |8.4.2| | 2 |
| Front brake application uneven | 2 |
| Brake hose excessively deteriorated | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear brake disc excessively scored |3.5.1h| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Central Rear Seat belt missing (7.1.2 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear Boot lid component damaged and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Towbar component insecure |6.6.1| | 1 |
| Towbar component excessively corroded |6.6.1| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Front brake caliper securing device loose |3.5.1j| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Centre Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
| Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear An item not tested |Manual| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| An item not tested |Manual| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Front front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Side repeater not working |1.4.A.2c| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Upper Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Hand operated control valve control cannot be moved over its full travel |3.2.1c| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Windscreen has damage | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside brake disc excessively scored |3.5.1h| | 1 |
| Offside Front Lower Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
| Offside Rear Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Upper Fuel pipe leaking |7.2.3| | 1 |
| Offside Rear Upper Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Outer Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |