| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 16 |
| Headlamp aim out of alignment | 15 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 10 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 8 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 7 |
| Rear brake binding | 7 |
| Brakes imbalanced across an axle | 6 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Registration plate lamp issues | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Registration plate issues | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside front brake binding |3.7.B.1| | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Outer Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Front Front wheel bearing rough when rotated both front |2.5.A.2| | 1 |
| Offside Rear Lower Shock absorber insecure bolt loose |2.7.2b| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Rear Brake lining(s) contaminated (1.1.13 (b)) | 1 |
| Rear Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Rear brake application uneven | 1 |
| Horn not working |1.6.2a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Service brake application uneven across the axle |3.7.D.2b| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases whole system |7.1.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |