Most common failures | No# failures |
---|
Brake pipe excessively corroded | 30 |
Headlamp aim out of alignment | 22 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 18 |
Registration plate lamp issues | 16 |
Windscreen wiper does not clear the windscreen effectively | 14 |
Nearside Steering rack gaiter split |2.2.D.2d| | 14 |
Brakes imbalanced across an axle | 13 |
Registration plate issues | 12 |
Rear brake binding | 11 |
Offside Steering rack gaiter split |2.2.D.2d| | 11 |
Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Offside Rear fog lamp not working |1.3.2b| | 9 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Rear brake application uneven | 8 |
Rear parking brake recording little or no effort | 7 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 7 |
Offside rear brake recording little or no effort |3.7.B.5a| | 6 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 6 |
Parking brake: efficiency below requirements |3.7.B.7| | 6 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 4 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Windscreen has damage | 3 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 3 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Headlamp insecure |1.7.3| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Emissions not tested (8.2.1.2 (d)) | 2 |
Rear passenger door does not latch securely closed |6.2.B.1a| | 2 |
passenger door does not latch securely closed |6.2.B.1a| | 2 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Battery insecure |1.9.1| | 2 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 2 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 2 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Tailgate cannot be secured in the closed position |6.4.1| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Nearside Ball joint has excessive play |2.2.B.1f| | 2 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
Indicator switch faulty |1.4.A.1| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 2 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Offside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Brake cable has restricted free movement |3.5.1k| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Outer Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded under sill by spring anchor |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded under sill by spring shackle |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded under sill and inner wheel arch by spring anchor |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded shock absorber mounting brackets |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded inner wheel arch and shock absorber mounting brackets |2.4.A.3| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded outer sill and floor pan along sill |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
Vehicle structure excessively corroded within 30cm of towbar mounting rear cross member |6.6.6| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring hanger (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis leg (5.3.6 (a) (i)) | 1 |
Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Rear Tailgate cannot be secured in the closed position |6.4.1| | 1 |
Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
Front Service brake effort inadequate at a wheel both sides (1.2.1 (a) (i)) | 1 |
Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
Braking system leaking |3.6.A.1| | 1 |
Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Front Headlamp switch faulty |1.7.1| | 1 |
Offside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Hazard warning switch missing |1.4.B.1d| | 1 |
Steering rack deformed and unserviceable |2.2.C.1d| | 1 |
Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Front Headlamp not working on dipped beam Both sides (4.1.1 (a) (ii)) | 1 |
Rear Exhaust has a major leak of exhaust gases SILENCER. |7.1.2| | 1 |
Emissions not tested DUE TO MAJOR EXHAUST LEAK. |7.3.A.1| | 1 |
Emissions not tested |7.3.A.1| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Obligatory mirror missing |8.1.1| | 1 |
Nearside Rear Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
Offside Rear Position lamp lens seriously defective lens damaged (4.2.1 (b)) | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Steering column universal joint insecure |2.1.5| | 1 |
Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Rear Loading door cannot be secured in the closed position |6.4.1| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Nearside Rear Shock absorber missing |2.7.1b| | 1 |
Offside Rear Shock absorber missing |2.7.1b| | 1 |
Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Rear Inner Suspension spring mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
Nearside Rear Outer Suspension spring mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Brake load sensing valve inoperative |3.6.E.3| | 1 |
Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Windscreen wiper blade insecure | 1 |
Rear Exhaust has a major leak of exhaust gases silencer
|7.1.2| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Vehicle structure inadequately repaired such that structural rigidity is significantly reduced wing arch (6.1.1 (d) (i)) | 1 |
Offside Rear Vehicle structure inadequately repaired such that structural rigidity is significantly reduced (6.1.1 (d) (i)) | 1 |
Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill and flor (6.2.2 (d) (i)) | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Offside Steering rack insecure |2.2.B.1a| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Steering rack gaiter missing |2.2.D.2d| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Lower Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill near front spring hanger |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner and outer sill by leaf spring mount |2.4.A.3| | 1 |
Central Exhaust has a major leak of exhaust gases part of exhaust |7.1.2| | 1 |
Emissions not tested due to exhaust and vehicles idling very poor and cuts out |7.3.A.1| | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount area (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring mount area (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount area (5.3.6 (a) (i)) | 1 |
Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear Parking brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
Brake hose excessively deteriorated | 1 |
Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring hangar |5.3.6 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring hangar |5.3.6 |a| |i|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |