| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 9 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Offside Steering rack gaiter split |2.2.D.2d| | 4 |
| Registration plate lamp issues | 4 |
| Rear Mechanical brake component has restricted free movement | 4 |
| Brake pipe excessively corroded | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 2 |
| Rear brake binding | 2 |
| Registration plate issues | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Windscreen washer not working | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear fog lamp switch not operating in accordance with the requirements Not keeping fog lamps on when released. (4.5.3 (a)) | 1 |
| Electrical wiring likely to touch hot or rotating parts Starter motor wiring rubbing on steering shaft (4.11 (a) (iii)) | 1 |
| Electrical wiring likely to touch hot or rotating parts Oil level sensor wiring hanging on heat shield and almost touching exhaust. (4.11 (a) (iii)) | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Radius arm severely distorted |2.4.G.1| | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Brake hose excessively damaged both showing cords (1.1.12 (b) (ii)) | 1 |
| Nearside Rear Brake pivot has restricted free movement (1.1.15 (e)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Rear Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Steering component cracked and unserviceable |2.2.C.1d| | 1 |
| Front Fuel hose leaking hose from fuel pump |7.2.3| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Steering component damaged and unserviceable |2.2.C.1d| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Lower Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Lower Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Speedometer clearly inoperative |6.7.2| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Headlamp aim beam image obviously incorrect Both front, lens deteriorated |1.8.A.1b| | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement Diff arm, AS PER MARKED |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement Diff arm, AS PER MARKED |2.4.G.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded Floor pan, AS PER MARKED |2.4.A.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering rack fractured and unserviceable |2.2.C.1d| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected inner arch (5.3.6 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |