| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 38 |
| Registration plate lamp issues | 38 |
| Windscreen wiper does not clear the windscreen effectively | 31 |
| Brake pipe excessively corroded | 24 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 23 |
| Brakes imbalanced across an axle | 19 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 18 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 16 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
| Nearside Stop lamp not working |1.2.1b| | 9 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 7 |
| Rear brake binding | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 6 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 6 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 5 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 5 |
| Registration plate issues | 5 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 5 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Emissions not tested |7.0| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Front brake application uneven | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front constant velocity joint is excessively worn |2.5.C.1b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Offside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill holed (6.1.1 (c) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases blower (6.1.2 (a)) | 1 |
| Emissions not tested blowing exhaust (8.2.1.2 (d)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outersill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill end/inner arch (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner arch (7.1.1 (a) (i)) | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear Anti-roll bar fractured |2.4.G.1| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage likely to become detached fixing loose (5.3.3 (a) (ii)) | 1 |
| Emissions unable to be completed engine running badly (8.2.1.2 (d)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting rear sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting rear sill (6.2.2 (d) (i)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Offside Outer Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired sill area corroded (6.2.2 (d) (ii)) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear brake disc has restricted free movement |3.5.1j| | 1 |
| Offside Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Steering linkage ball joint ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Rear Service brake effort inadequate at a wheel nearside and offside (1.2.1 (a) (i)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Nearside Front drive shaft support bearing excessively worn |2.5.C.2c| | 1 |
| Offside Front drive shaft support bearing excessively worn |2.5.C.2c| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Upper Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Stop lamp not working |1.2.1b| | 1 |
| Nearside Front suspension locking device missing |2.5.A.4| | 1 |
| Offside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Suspension arm locating pin retaining device missing |2.4.G.3b| | 1 |
| Nearside Front Suspension arm locating pin retaining device missing |2.4.G.3b| | 1 |
| Obligatory mirror insecure |8.1.1| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Rear brake application uneven | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Centre Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Nearside Front Lower Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Offside Front Lower Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Centre Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |