Most common failures | No# failures |
---|
Headlamp aim out of alignment | 55 |
Brake pipe excessively corroded | 53 |
Parking brake: efficiency below requirements |3.7.B.7| | 44 |
Rear parking brake recording little or no effort | 30 |
Service brake: efficiency below requirements |3.7.B.7| | 27 |
Windscreen wiper does not clear the windscreen effectively | 27 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 24 |
Registration plate lamp issues | 19 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 18 |
Nearside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 14 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 14 |
Offside Rear fog lamp not working |1.3.2b| | 13 |
Offside rear brake recording little or no effort |3.7.B.5a| | 12 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 12 |
Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Rear Sub-frame corroded and seriously weakened |2.4.G.1| | 10 |
Rear brake binding | 10 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 10 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 9 |
Offside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 9 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Nearside Stop lamp not working |1.2.1b| | 8 |
Emissions not tested |7.0| | 8 |
Nearside Rear Radius arm has excessive play in a pin/bearing |2.4.G.2| | 8 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 7 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 7 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 6 |
Fuel tank leaking |7.2.3| | 6 |
Offside Front Fluid suspension has no suspension movement |2.4.D.5| | 6 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Offside Rear Radius arm has excessive play in a pin/bearing |2.4.G.2| | 6 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 6 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 5 |
Windscreen wiper blade insecure | 5 |
Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 4 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Registration plate issues | 4 |
Windscreen has damage | 4 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
Stop lamp not working |1.2.1b| | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 3 |
Rear Rear fog lamp not working |1.3.2b| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 3 |
Nearside Front Fluid suspension has no suspension movement |2.4.D.5| | 3 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Rear Exhaust system not adequately supported |7.1.1| | 3 |
Brake cable has restricted free movement |3.5.1k| | 3 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Nearside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 3 |
Front Fluid suspension has no suspension movement |2.4.D.5| | 3 |
Nearside Side repeater not working |1.4.A.2c| | 3 |
Brakes imbalanced across an axle | 3 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
Offside Rear Brake clevis joint has restricted free movement |3.5.1k| | 3 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Fluid suspension has no suspension movement |2.4.D.5| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 2 |
Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Front Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Rear brake application uneven | 2 |
Direction indicator incorrect colour |1.4.A.2f| | 2 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
Nearside Rear Brake clevis joint has restricted free movement |3.5.1k| | 2 |
Nearside Gas suspension has no suspension movement |2.4.D.5| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Nearside Rear Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Gas suspension accumulator leaking |2.4.D.2| | 1 |
Offside Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Front Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Outer Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Front Fluid suspension unit totally deflated |2.4.D.1a| | 1 |
Rear Sub-frame fractured |2.4.G.1| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front Upper Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Front Upper Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Front Gas suspension unit totally deflated |2.4.D.1a| | 1 |
Offside Front Gas suspension unit totally deflated |2.4.D.1a| | 1 |
Nearside Rear Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Offside Front Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Rear fog lamp flickers when tapped lightly by hand |1.1.6d| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Offside Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Body has a projection caused by damage |6.1.C.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Suspension arm synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Front Sub-frame severely distorted |2.4.G.1| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Side repeater incorrect colour |1.4.A.2f| | 1 |
Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Rear Fluid suspension unit supply pipe corroded and seriously weakened |2.4.D.3| | 1 |
Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Lower Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Lower Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Radius arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Trailing arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Rear Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Rear Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Inner Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
An item not tested |Manual| | 1 |
Nearside Side repeater insecure |1.4.A.2b| | 1 |
Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Front Fluid suspension unit totally deflated |2.4.D.1a| | 1 |
Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Nearside Front Fluid suspension unit fouled by moving parts likely to restrict travel |2.4.D.1c| | 1 |
Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Front Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
Front Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Offside Rear fog lamp insecure |1.3.2a| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Side repeater insecure |1.4.A.2b| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Fluid suspension has no suspension movement |2.4.D.5| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Rear Fluid suspension pipe leaking |2.4.D.2| | 1 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Rear An item not tested |Manual| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Nearside Rear Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
Nearside Front brake caliper securing device missing |3.5.1j| | 1 |
Nearside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |