| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Rear parking brake recording little or no effort | 15 |
| Registration plate lamp issues | 12 |
| Rear brake binding | 7 |
| Brakes imbalanced across an axle | 7 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear brake application uneven | 3 |
| Headlamp aim out of alignment | 3 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 3 |
| Headlamp switch faulty |1.7.1| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Braking system leaking |3.6.A.1| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Front Steering locking device missing |2.2.C.1g| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Offside Front Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner seal |6.1.B.2| | 1 |
| Brake pipe likely to become detached or damaged front to rear (1.1.11 (d) (ii)) | 1 |
| Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
| Offside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
| Offside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Braking system leaking Front Joints |3.6.A.1| | 1 |
| Offside Front Brake pipe leaking 4 way to Caliper Pipe |3.6.A.1| | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Suspension arm attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Nearside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamps matched pair are not the same colour (4.1.4 (d)) | 1 |
| Headlamp not working on main beam BOTH n/s & o/s |1.7.5a| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Centre Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Brake disc contaminated Near and Offside (1.1.14 (b)) | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Windscreen washer control missing |8.2.1a| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Lower Shock absorber detached |2.7.2b| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Stop lamp(s) switch with a delay in operation (4.3.2 (a) (ii)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Floor to Sill (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Floor to Sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |