Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 25 |
Brake pipe excessively corroded | 20 |
Headlamp aim out of alignment | 14 |
Rear parking brake recording little or no effort | 12 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 10 |
Rear brake binding | 10 |
Offside Stop lamp not working |1.2.1b| | 9 |
Service brake: efficiency below requirements |3.7.B.7| | 8 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Nearside Stop lamp not working |1.2.1b| | 7 |
Parking brake lever has no reserve travel |3.1.6b| | 6 |
Registration plate lamp issues | 6 |
Registration plate issues | 5 |
Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
Horn not working |1.6.2a| | 4 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Headlamp not working on main beam |1.7.5a| | 4 |
Brake hose excessively deteriorated | 4 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Front front brake binding |3.7.B.1| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
Offside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
Battery insecure |1.9.1| | 2 |
Nearside Front Braking system leaking |3.6.A.1| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Brakes imbalanced across an axle | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Service brake: efficiency below requirements |3.7.C.1a| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Front Headlamp aim beam image obviously incorrect both sides |1.8.A.1b| | 2 |
Rear Fluid suspension levelling valve leaking both sides |2.4.D.2| | 2 |
Nearside Front Road wheel badly damaged |4.2.A.1a| | 2 |
Offside Rear Fluid suspension supply pipe insecure |2.4.D.3| | 2 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Fuel tank leaking |7.2.3| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Rear brake disc in such a condition that it is seriously weakened | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Side repeater not working |1.4.A.2c| | 2 |
Nearside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Headlamp not working on dipped beam O/S |1.7.5a| | 1 |
Suspension arm has excessive play in a ball joint O/S/F LOWER |2.4.G.2| | 1 |
Suspension arm has excessive play in a ball joint N/S/F LOWER |2.4.G.2| | 1 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Fuel system component insecure fuel pump |7.2.1| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front Fuel hose leaking |7.2.3| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
An item not tested |Manual| | 1 |
Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Steering column flexible coupling is excessively deteriorated |2.2.2 |c|| | 1 |
Suspension accumulator leaking |5.3.5 |c|| | 1 |
Nearside Rear Brake valve leaking |3.6.A.1| | 1 |
Rear brake application uneven | 1 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Offside Inner Ball joint ball pin shank loose |2.2.B.1c| | 1 |
Offside Rear Inner Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Centre Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded sill holed and cracked |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded lower inner wheel arch holed |2.4.A.3| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Inner Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Stop lamp(s) switch with a delay in operation (4.3.2 (a) (ii)) | 1 |
Nearside Front Tie bar/rod rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Tie bar/rod rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Windscreen washer not working | 1 |
Nearside Rear Brake hose twisted |3.6.B.4c| | 1 |
Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Centre Brake pipe inappropriately repaired |3.6.A.3| | 1 |
Centre Braking system leaking |3.6.A.1| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Steering column flexible coupling fractured and unserviceable |2.2.C.1d| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Front Torque/reaction arm has a deteriorated synthetic bush resulting in excessive movement |2.4.G.2| | 1 |
Rear Fuel hose leaking |7.2.3| | 1 |
Windscreen has damage | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Front Windscreen wiper not working (3.4 (a)) | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Rear Exhaust system insecure |6.1.2 |a|| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear Stop lamp|s| adversely affected by the operation of another lamp Wiring system faulty |4.3.3 |b|| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
front brake binding |3.7.B.1| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
Steering column universal joint is excessively deteriorated |2.1.5| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Steering box has a significant oil leak |2.2.D.2e| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Fuel system component leaking |7.2.3| | 1 |
Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
Bootlid cannot be secured in the closed position |6.4.1| | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front brake application uneven | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Rear Brake clevis joint excessively damaged and seriously weakened |3.5.1e| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Rear Rear position lamp|s| not working side marker |1.1.A.3b| | 1 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Exhaust has a major leak of exhaust gases manifold area |7.1.2| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Front Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |