| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Brake pipe excessively corroded | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Registration plate lamp issues | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Brakes imbalanced across an axle | 2 |
| Headlamp aim out of alignment | 2 |
| Registration plate issues | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Macpherson strut insecure |2.4.G.1| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Outer Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Hydraulic brake calliper leaking front (1.1.16 (b) (i)) | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Offside Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Rear Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Rear Lower Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear brake application uneven | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |