| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Registration plate lamp issues | 2 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Windscreen has damage | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Registration plate issues | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |