| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Headlamp aim out of alignment | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Parking brake: efficiency below requirements (3.7.B.7) | 2 |
| Centre Rear Rear position lamp|s| missing marker light and trim panel missing |1.1.A.3a| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc gaitor weaping |2.5.C.1a| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Front Side repeater likely to become detached (4.4.1 (c) (ii)) | 1 |
| Offside Front Side repeater likely to become detached mounting damaged (4.4.1 (c) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Rear Integral body structure strengthening plate or fastening insecure body n/s/f bolts loose x2 (6.1.1 (b) (i)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Emissions not tested engine wont rev up (8.2.2.2 (e)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Anti-roll bar pin or bush excessively worn both D bushes (5.3.4 (a) (i)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn n/s o/s (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake disc contaminated axle seal leaking (1.1.14 (b)) | 1 |
| Nearside Front Body mounting fixings insecure such that stability is seriously impaired (6.2.2 (c) (ii)) | 1 |
| Offside Body mounting fixings insecure such that stability is seriously impaired centre (6.2.2 (c) (ii)) | 1 |
| Offside Front Body mounting fixings insecure such that stability is seriously impaired (6.2.2 (c) (ii)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced back of cab (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced back of cab (7.1.1 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached loose in arm |5.3.4 |a| |ii|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Offside Rear fog lamp lens defective such that emitted light is adversely affected |4.5.1 |b| |ii|| | 1 |
| Nearside Rear Upper Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Outline marker lamp missing side marker |4.2.1 |a|| | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wing under seat |7.1.1 |a| |i|| | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wing under seat |7.1.1 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Body insecure and dangerous to other road users One body bolt missing on nearside plus other bolts loose on both nearside and offside of vehicle. |6.1.B.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Outline marker lamp missing |4.2.1 |a|| | 1 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Brake disc contaminated (1.1.14 (b)) | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting floor/behind headlamp (6.2.2 (d) (i)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system leaking where clipped in chassis (1.1.11 (b) (ii)) | 1 |
| Nearside Rear Brake disc contaminated half shaft seal leaking (1.1.14 (b)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Registration plate issues | 1 |
| Fuel pipe leaking Or pipes (6.1.3 (b) (i)) | 1 |
| Nearside Side repeater likely to become detached (4.4.1 (c) (ii)) | 1 |
| Front Outline marker lamp not working Both (4.2.1 (a)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Centre Upper Stop lamp not working |1.2.1b| | 1 |
| Headlamp aim beam image obviously incorrect offside (1.8.A.1b) | 1 |
| Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement nearside front (2.4.G.2) | 1 |
| Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement offside front (2.4.G.2) | 1 |
| Anti-roll bar linkage has excessive play in a ball joint nearside front (2.4.G.2) | 1 |
| Anti-roll bar linkage has excessive play in a ball joint offside front (2.4.G.2) | 1 |
| Nearside Front Shock absorber has an excessively worn bush (2.7.4) | 1 |
| Offside Front Shock absorber has an excessively worn bush (2.7.4) | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint (2.5.B.1a) | 1 |