| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 50 |
| Parking brake: efficiency below requirements |3.7.B.7| | 46 |
| Windscreen wiper does not clear the windscreen effectively | 30 |
| Anti-lock braking system warning lamp indicates an ABS fault | 28 |
| Registration plate lamp issues | 21 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 20 |
| Parking brake lever has no reserve travel |3.1.6b| | 16 |
| Brake pipe excessively corroded | 13 |
| Rear parking brake recording little or no effort | 12 |
| Horn not working |1.6.2a| | 10 |
| Windscreen washer not working | 9 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 9 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
| Service brake: efficiency below requirements |3.7.B.7| | 9 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 9 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 8 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 7 |
| Brakes imbalanced across an axle | 7 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 7 |
| Nearside Headlamp not working on main beam |1.7.5a| | 7 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 6 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 6 |
| Nearside Side repeater not working |1.4.A.2c| | 6 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 6 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Windscreen has damage | 5 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 5 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Horn not working (7.7 (a) (ii)) | 4 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 4 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 3 |
| Offside Rear Brake disc contaminated (1.1.14 (b)) | 3 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Rear Brake disc contaminated |1.1.14 |b|| | 3 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 3 |
| Horn not working |7.7 |a| |ii|| | 3 |
| Registration plate issues | 3 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 3 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 3 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Offside Front Side repeater insecure |1.4.A.2b| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Brake disc contaminated (1.1.14 (b)) | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 2 |
| Nearside Side repeater missing |1.4.A.2b| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Rear brake application uneven | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Parking brake: efficiency below requirements |3.7.D.4| | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Rear brake binding | 2 |
| Fuel tank insecure |7.2.1| | 2 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Rear Brake disc contaminated hub seal leaking oil onto disc (1.1.14 (b)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Additional braking device insecure |3.6.I.1| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Rear Fuel tank insecure strap broken (6.1.3 (a) (i)) | 1 |
| Nearside Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Trailer electrical socket likely to become detached (4.10 (a) (ii)) | 1 |
| Fuel tank insecure front tank strap broken |6.1.3 |a| |i|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Driver`s seat insecure floor excessively corroded |6.2.5 |a| |ii|| | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Rear Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Nearside Rear Brake disc contaminated hub seal leak (1.1.14 (b)) | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Rear fog lamp emits a light other than red O/S Rear light lens broken |1.3.2e| | 1 |
| Nearside Front Upper Shock absorber has an excessively worn bush Top mounting U/S |2.7.4| | 1 |
| Shock absorber has an excessively worn bush O/S & N/S Rear lower shock absorber bushes worn |2.7.4| | 1 |
| Anti-roll bar linkage worn and seriously weakened O/S & N/S front anti roll bar linkages U/S |2.4.G.1| | 1 |
| Anti-roll bar has excessive play in a pin/bush O/S & N/S Rear lower anti roll link bushes worn |2.4.G.2| | 1 |
| Anti-roll bar has excessive play in a pin/bush N/S Rear anti roll bar to axle bush worn |2.4.G.2| | 1 |
| Offside Stop lamp emits other than a steady red light Lens faded |1.2.1e| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Front Lower Shock absorbers has an excessively worn bush nearside and offside (5.3.2 (c)) | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear brake disc contaminated by brake fluid |3.5.1h| | 1 |
| Offside Rear brake disc contaminated by brake fluid |3.5.1h| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Rear Position lamp adversely affected by the operation of another lamp Both (4.2.3 (c)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn Both (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-lock braking system component missing |3.4.2| | 1 |
| Offside Rear Anti-lock braking system component missing |3.4.2| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Brake hose inappropriately repaired |3.6.A.3| | 1 |
| Nearside Obligatory mirror missing |3.3 |a|| | 1 |
| Direction indicator not working Both |4.4.1 |a| |ii|| | 1 |
| Rear Position lamp not working Both |4.2.1 |a|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| All outline marker lamps not working |4.2.1 |a|| | 1 |
| Front Shock absorber has an excessively worn shock absorber pivot Both sides |2.7.4| | 1 |
| Nearside Rear Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush D bushes both |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Anti-roll bar pin or bush excessively worn x2 |5.3.4 |a| |i|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Road wheel more than one fixing loose (5.2.1 (a) (ii)) | 1 |
| Floor in such a condition it is likely to cause load insecurity or instability (6.2.4 (a) (ii)) | 1 |
| Nearside Body mounting fixings insecure 1st and 2nd bolt loose (6.2.2 (c) (i)) | 1 |
| Offside Front Body mounting fixings insecure 1st and 2nd bolts (6.2.2 (c) (i)) | 1 |
| Offside Rear Brake disc contaminated hub seal leaking (1.1.14 (b)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Rear Brake disc contaminated (1.1.14 (b)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Rear Brake disc contaminated x2 (1.1.14 (b)) | 1 |
| Central Exhaust has a major leak of exhaust gases Back Box to pipe broken (6.1.2 (a)) | 1 |
| Nearside Front Body component damaged and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded Offside front seat belt mounting and seat rotten |5.2.6| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Front Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Battery insecure |1.9.1| | 1 |
| Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Brake hose excessively stretched (1.1.12 (b) (ii)) | 1 |
| Offside Front Seat belt anchorage likely to become detached in the event of a collision (7.1.1 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Offside Front Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Fuel cap/sealing device component leaking (6.1.3 (b) (i)) | 1 |
| Rear Dropside component likely to become detached both pivot pins cracked and corroded (6.2.1 (a) (ii)) | 1 |
| Dropside component corroded and likely to cause injury corroded and holes throughout tipper body both sides (6.2.1 (a) (i)) | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Side repeater flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush nearside and offside |2.4.G.2| | 1 |
| Front Upper Suspension arm has excessive play in a ball joint nearside and offside |2.4.G.2| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner arch in 2 places marked yellow (7.1.1 (a) (i)) | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush both sides |2.4.G.2| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Front Wheel nut|s| loose nearside |4.2.A.1e| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch |6.1.B.2| | 1 |
| Nearside Rear brake disc contaminated by grease |3.5.1h| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Valve stem seriously damaged Leaking air (5.2.3 (j)) | 1 |
| Exhaust has a major leak of exhaust gases Rear exhaust box separated from pipe (6.1.2 (a)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Drivers seat mount excessively corroded in wheel arch - Seat partially lose (7.1.1 (a) (i)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Rear Brake lever has restricted free movement caliper arm seized (1.1.15 (e)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested Exhaust has a major leak of gases (8.2.2.2 (e)) | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Nearside Rear Inner Anti-roll bar pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Inner Anti-roll bar pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement Upper and lower bushes worn |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint Upper arm, outer ball joint |2.4.G.2| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Front of inner arch/cab floor (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Front of inner arch/cab floor (6.1.1 (c) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cab floor (6.2.2 (d) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced cab floor stiffener near seat mounting (7.1.1 (a) (i)) | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush bush missing |2.4.G.2| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn d bush worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn d bush worn (5.3.4 (a) (i)) | 1 |
| Front Inner Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing/floor holes (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing/floor holes (5.3.6 (a) (i)) | 1 |
| Nearside Rear Lower Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
| Nearside Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cabin sill holed at prescribed area [seat belt bolt] |6.1.B.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement rubber bush split open |2.4.G.2| | 1 |
| Nearside Rear Inner Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement d-bushes worn and bush at axle worn resulting in xs movement |2.4.G.2| | 1 |
| Offside Rear Inner Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement d-bush worn and bush at axle worn resulting xs movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Outer Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Brake pedal anti-slip provision worn smooth worn to metal/holed |1.1.2 |c|| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn d bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn d bush |5.3.4 |a| |i|| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn end bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn end bush |5.3.4 |a| |i|| | 1 |
| Nearside Rear Lower Shock absorbers insecurely attached |5.3.2 |a| |i|| | 1 |
| Offside Rear Lower Shock absorbers insecurely attached |5.3.2 |a| |i|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Inner Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Inner Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Body panel corroded and likely to cause injury body side rail |6.2.1 |a| |i|| | 1 |
| Rear Body panel corroded and likely to cause injury body rail |6.2.1 |a| |i|| | 1 |
| Rear Body mounting fixings insecure bed (6.2.2 (c) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting bulkhead behind seats (6.2.2 (d) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) steering column universal joint excessively worn (2.3 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear position lamp|s| not working BOTH |1.1.A.3b| | 1 |
| Side repeater not working BOTH |1.4.A.2c| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear brake disc contaminated by oil hub oil seal |3.5.1h| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush d bushes |2.4.G.2| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush d bushes |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush drop link |2.4.G.2| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Driver`s seat insecure heavily corrded |6.2.A.1| | 1 |
| Nearside Rear Parking |secondary brake| on a single line braking system has no recorded effort at a wheel |1.3.1 |a| |ii|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Front Road wheel fixings not compatible (5.2.2 (d)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Anti-roll bar likely to fail (5.3.3 (b) (ii)) | 1 |
| Nearside Front Outline marker lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced under wheel arch (6.1.1 (d) (i)) | 1 |
| Offside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced under wheel arch (6.1.1 (d) (i)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Drivers view of an obligatory external mirror significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front All position lamps excessively damaged so they are not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust has a major leak of exhaust gases Front pipe snapped |7.1.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
| Nearside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
| Nearside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded cab floor |inner wing area| |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded cab floor |inner wing area| |5.2.6| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassie in sev places |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis in sev places |6.1.B.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Electrical wiring insecure |1.9.2a| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Parking brake efficiency below requirements 180kgf no lock (1.4.2 (a) (i)) | 1 |
| Offside Parking brake efficiency below requirements 100kgf no lock (1.4.2 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn saddle bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn bush at end of anti roll bar (5.3.4 (a) (i)) | 1 |
| Front Position lamp not working both side lights out |4.2.1 |a|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Brake pipe inadequately clipped at hose |3.6.B.1| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bearing both saddle bushes |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front Body insecure and dangerous to other road users mud gaurd |6.1.B.1b| | 1 |
| Rear Prop shaft joint so worn it is likely to fail (6.1.7 (c) (ii)) | 1 |
| Cab or chassis has excessive corrosion to the extent that overall security or stability of the cab is impaired entire floor pan of cab and locking mounts (6.2.2 (d) (ii)) | 1 |
| Fuel tank insecure (6.1.3 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour light cover broken |1.1.A.3e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Front Front suspension has excessive play in a upper suspension ball joint both |2.5.B.1a| | 1 |
| Front Front suspension has excessive play in a lower suspension ball joint both lower |2.5.B.1a| | 1 |
| Offside Front Body insecure and dangerous to other road users mudwing |6.1.B.1b| | 1 |
| Front front brake binding both |3.7.B.1| | 1 |
| Power steering pipe|s| or hose|s| leaking pipe |2.3.3b| | 1 |
| Anti-roll bar has excessive play in a pin/bush all rear |2.4.G.2| | 1 |
| Rear Shock absorber has a serious fluid leak both |2.7.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected inner wing at road wheel holed |5.3.6 |a| |ii|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing at roadwheel holed |5.3.6 |a| |i|| | 1 |
| Offside Front Body component insecure wing |6.2.1 |a| |i|| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings at pivot mounts |6.1.B.2| | 1 |
| Offside Rear Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings at tipper mounts |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear rear brake recording little or no effort foot or parking brake |3.7.B.5a| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement inner and outer bushes both sides |2.4.G.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Offside Rear Cab steps in such a condition that it is likely to cause injury |6.2.8 |b|| | 1 |
| Nearside Rear Cab steps in such a condition that it is likely to cause injury |6.2.8 |b|| | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Front Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Brake hose excessively deteriorated | 1 |
| Rear Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Front Brake pipe likely to become detached or damaged |1.1.11 |d| |ii|| | 1 |
| Front Bumper insecure |6.1.4 |a| |i|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Rear Shock absorbers insecurely attached |5.3.2 |a| |i|| | 1 |
| Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Emissions not tested |8.2.2.2 |e|| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| All position lamps not working Nearside marker light |1.1.A.3b| | 1 |
| All position lamps not working Offside marker light |1.1.A.3b| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Body insecure and dangerous to other road users Front body mounting bolts loose |6.1.B.1b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |