Most common failures | No# failures |
---|
Headlamp aim out of alignment | 64 |
Parking brake: efficiency below requirements |3.7.B.7| | 51 |
Rear parking brake recording little or no effort | 47 |
Windscreen wiper does not clear the windscreen effectively | 37 |
Registration plate lamp issues | 26 |
Parking brake lever has no reserve travel |3.1.6b| | 18 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 11 |
Brake pipe excessively corroded | 10 |
Horn not working |1.6.2a| | 8 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 6 |
Battery insecure |1.9.1| | 6 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Brakes imbalanced across an axle | 5 |
Anti-lock braking system warning lamp indicates an ABS fault | 4 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
Offside Front Shock absorbers has a serious fluid leak | 4 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
Nearside Headlamp insecure |1.7.3| | 4 |
Front brake excessively fluctuating | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
Offside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 3 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
Offside Front Position lamp not working |4.2.1 |a|| | 3 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Registration plate issues | 3 |
Brake lever has insufficient reserve travel (1.1.2 (a)) | 3 |
Windscreen washer not working | 3 |
Rear brake disc in such a condition that it is seriously weakened | 3 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Front brake application uneven | 2 |
Windscreen has damage | 2 |
Nearside Front Shock absorbers has a serious fluid leak | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Hazard warning switch faulty |1.4.B.1d| | 2 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 2 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Horn not working (7.7 (a)) | 2 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 2 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Offside Front Brake pipe twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Brake lever has insufficient reserve travel handbrake (1.1.2 (a)) | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Windscreen wiper blade missing |8.2.2| | 1 |
Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
Central Rear Seat belt retracting mechanism defective |7.1.2 |e|| | 1 |
Hazard warning switch inoperative won`t switch off |4.4.2 |a| |ii|| | 1 |
Nearside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
Nearside Front Coil spring fractured or broken shorter than off side |5.3.1 |b| |i|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Headlamp not working on dipped beam |1.7.5a| | 1 |
Hazard warning switch insecure |1.4.B.1d| | 1 |
Offside Rear Additional braking device component damaged hqandbrake cable broken |3.6.I.1| | 1 |
Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Windscreen wiper blade insecure | 1 |
Offside Windscreen wiper blade missing |8.2.2| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D bush |2.4.G.2| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D bush |2.4.G.2| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt top. |2.4.G.2| | 1 |
Offside Headlamp insecure |4.1.1 |c|| | 1 |
Nearside Rear Road wheel badly distorted |5.2.2 |c| |i|| | 1 |
Offside Rear Road wheel badly distorted |5.2.2 |c| |i|| | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Front Position lamp not working Both (4.2.1 (a) (ii)) | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
Power steering fluid level below minimum |2.3.1| | 1 |
Offside Rear Braking system leaking caliper |3.6.A.1| | 1 |
Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Offside Rear Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Emissions not tested Due to exhaust blow |8.2.1.2 |d|| | 1 |
Exhaust emissions likely to be affected by an exhaust leak |8.2.2.1 |b|| | 1 |
Exhaust has a major leak of exhaust gases Universal flexi exhaust leaking from joins |6.1.2 |a|| | 1 |
Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Macpherson strut worn and seriously weakened |2.4.G.1| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 1 |
Brake hose has insufficient room to move | 1 |
Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Nearside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
Fuel pipe insecure |7.2.1| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Radius arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Nearside Front All position lamps light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Front Road wheel fixing missing nut |5.2.1 |a| |i|| | 1 |
Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Brake performance not tested Brake pipe fracture on rbt (1.2.1 (g)) | 1 |
Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Wing (6.2.2 (d) (i)) | 1 |
Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Wing (6.2.2 (d) (i)) | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Floor near jack point (6.2.2 (d) (i)) | 1 |
Headlamp aim projected beam image is obviously incorrect both lamps (4.1.2 (c)) | 1 |
Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Emissions not tested Low flow (8.2.1.2 (d)) | 1 |
Nearside Rear Brake linkage has restricted free movement At caliper (1.1.15 (e)) | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Nearside Rear Brake linkage has restricted free movement Caliper |1.1.15 |e|| | 1 |
Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Nearside Front Anti-roll bar linkage which is adjustable, locking device insecure |2.4.G.1| | 1 |
Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Mechanical brake component has restricted free movement | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Rear Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Offside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Rear Anti-roll bar linkage pin or bush excessively worn droplink (5.3.4 (a) (i)) | 1 |
Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Rear brake caliper leaking |3.6.A.1| | 1 |
Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake pedal anti-slip provision loose |3.3.A.1b| | 1 |
Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Offside Front Windscreen wiper not working (3.4 (a)) | 1 |
Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
Brake fluid significantly below minimum mark |1.1.10 |d| |ii|| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Headlamp not working on main beam both |1.7.5a| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Nearside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Front Power steering pipe|s| or hose|s| leaking infront f radiator |2.3.3b| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |