| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 48 |
| Windscreen wiper does not clear the windscreen effectively | 34 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 21 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Rear parking brake recording little or no effort | 11 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 10 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Registration plate lamp issues | 5 |
| Horn not working (7.7 (a) (ii)) | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 5 |
| Brake pipe excessively corroded | 5 |
| Horn not working (7.7 (a)) | 5 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Windscreen washer not working | 4 |
| Nearside Front Shock absorbers has a serious fluid leak | 4 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Battery insecure |1.9.1| | 3 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Horn not working |1.6.2a| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Offside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 2 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| rear parking |secondary| brakes imbalanced | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Offside Front Inner Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 2 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 2 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 2 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Brake pedal anti-slip provision loose (1.1.2 (c)) | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 2 |
| Registration plate issues | 2 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Nearside Front Headlamp levelling device inoperative (4.1.5 (a)) | 2 |
| Offside Front Headlamp levelling device inoperative (4.1.5 (a)) | 2 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Offside Rear Inner Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp aim not tested head lamp insecure |1.8.A.1c| | 1 |
| Offside Front Headlamp aim not tested head lamp insecure |1.8.A.1c| | 1 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Front brake application uneven | 1 |
| engine mounting bracket insecure and likely to fail |6.1.D.1b| | 1 |
| Power steering component|s| leaking steering rack |2.3.3b| | 1 |
| Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Inner Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Front Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Rear Braking system leaking poss caliper weeping/tightened banjo bolt |3.6.A.1| | 1 |
| Rear Anti-roll bar pin or bush excessively worn both rear d bushes |5.3.4 |a| |i|| | 1 |
| Front Anti-roll bar pin or bush excessively worn both front d bushes |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn d-bush |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn d-bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Seat belt locking mechanism does not secure or release middle |5.2.5a| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement d bushes |2.4.G.2| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement d bushes |2.4.G.2| | 1 |
| engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Front engine mounting bracket insecure and likely to fail |6.1.D.1b| | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Rear Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Rear Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Offside Front Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Offside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Brake cable has restricted free movement no operation when handbrake applied |1.1.15 |e|| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Lower Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Offside Front Lower Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush front bush |2.4.G.2| | 1 |
| Windscreen has damage | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Power steering component leaking |2.1.5 |a|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Fuel tank leaking |6.1.3 |b| |i|| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint power steering hose pipe joint leaking |2.3.3b| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Nearside Rear Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Road wheel more than one fixing missing bolt broken |5.2.1 |a| |ii|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Front Anti-roll bar pin or bush excessively worn both front D bushes (5.3.4 (a) (i)) | 1 |
| Offside Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt big clip missing (6.1.7 (g) (ii)) | 1 |
| Offside Front Position lamp not working sidelight (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect no pattern (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect no pattern (4.1.2 (c)) | 1 |
| Central Rear Seat belt damaged (7.1.2 (b) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Brake lever has insufficient reserve travel Handbrake (1.1.2 (a)) | 1 |
| Nearside Stop lamp not working (1.2.1b) | 1 |
| Parking brake: efficiency below requirements (3.7.B.7) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Rear Position lamp likely to become detached (4.2.1 (c) (ii)) | 1 |
| Rear Parking brake inoperative on one side Both (1.4.1 (a)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Hydraulic fluid leaking excessively (8.4.1 (a) (i)) | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Suspension arm ball joint dust cover missing (5.3.4 (b) (ii)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect bulb fitment - retaining clip broken (4.1.2 (c)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt insecure (2.1.3 (g) (ii)) | 1 |
| Offside Rear Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt clip broken (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases mid section from cat to back box blowing (6.1.2 (a)) | 1 |
| Indicator switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Emissions not tested excessive leak from exhaust system (8.2.1.2 (d)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage likely to become detached (5.3.3 (a) (ii)) | 1 |
| Nearside Rear Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage likely to become detached Snapped (5.3.3 (a) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Brake lever pivot has excessive wear or free play also ratchet does not hole on any teeth (1.1.1 (b)) | 1 |
| Lower Engine mounting bracket damaged or deteriorated resulting in excessive movement crossmember under engine corroded (6.1.8 (a) (i)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed due to exhaust leak (8.2.1.2 (d)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases FLEXI (6.1.2 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases front pipe flexi blowing (6.1.2 (a)) | 1 |
| Emissions unable to be completed due to flexi blowing (8.2.1.2 (d)) | 1 |
| Offside Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Brake hydraulic reservoir fluid level significantly below minimum level (1.1.10 (d) (ii)) | 1 |
| Brake lever not releasing correctly and functionality of brakes affected (1.1.2 (b) (ii)) | 1 |
| Brake lever pivot has excessive wear or free play (1.1.1 (b)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Front Outer Steering locking device missing Track Rod End (2.1.3 (d)) | 1 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect Dips wrong way (4.1.2 (c)) | 1 |
| Nearside Rear Brake disc insecure (1.1.14 (a) (ii)) | 1 |
| Offside Rear Brake disc insecure (1.1.14 (a) (ii)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |