| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 31 |
| Parking brake: efficiency below requirements |3.7.B.7| | 20 |
| Headlamp aim out of alignment | 16 |
| Rear parking brake recording little or no effort | 16 |
| Registration plate lamp issues | 9 |
| Brake pipe excessively corroded | 9 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 9 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 6 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 5 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
| Offside Front Position lamp not working |4.2.1 |a|| | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Brakes imbalanced across an axle | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 3 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Windscreen has damage | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Battery insecure |1.9.1| | 2 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 2 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 2 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Shock absorbers likely to become detached |5.3.2 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Power steering component|s| leaking pipe |2.3.3b| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Emissions not tested due to misfire being present -poor running |7.3.A.1| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Rear Inner Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure rubbing on inner wing |5.3.3 |a| |i|| | 1 |
| Offside Front Upper Macpherson strut insecurely attached |5.3.3 |a| |i|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect not working |1.8.A.1b| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Obligatory mirror missing door mirror glass |3.3 |a|| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Wheel bearing so rough it is likely to overheat or break up |5.1.3 |b| |ii|| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Power steering component|s| leaking to check location |2.3.3b| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Rear Stop lamp has less than 50% of the light sources illuminating both |1.2.1b| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| passenger door catch insecure bonnet |6.2.B.2| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Rear brake caliper securing device missing lower bolt missing. |3.5.1j| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Indicator switch faulty Nearside action not working |1.4.A.1| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front Macpherson strut damaged and seriously weakened |2.4.G.1| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Central Exhaust system not adequately supported rubber |7.1.1| | 1 |
| Nearside Front Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Offside Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Rear Seat belt not functioning as intended centre |7.1.2 |c|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Brake pedal anti-slip provision worn smooth |1.1.2 |c|| | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety |8.4.1 |a| |ii|| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Body component insecure spoiler (6.2.1 (a) (i)) | 1 |
| Nearside Front Body component insecure bumper (6.2.1 (a) (i)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Headlamp not working on dipped beam very low light output (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
| Exhaust system insecure rear exhaust rubbers broken x2 (6.1.2 (a)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Fuel system component leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt drop link (5.3.4 (b) (ii)) | 1 |
| Offside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn corroded (1.1.14 (a) (i)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt insecure (2.1.3 (g) (ii)) | 1 |
| Rear Anti-roll bar linkage damaged and seriously weakened both (5.3.3 (b) (i)) | 1 |
| Brake performance not tested Due to leak (1.2.1 (g)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Front Headlamp levelling device inoperative Both lamps (4.1.5 (a)) | 1 |
| Windscreen washer not working | 1 |
| Rear Exhaust system insecure mounting broken (6.1.2 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear or maladjustment No reserve on hand brake (1.1.15 (f)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Insecure (6.1.7 (g) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Lower Suspension arm corroded and seriously weakened wishbone (5.3.3 (b) (i)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Rear Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Power steering malfunctioning (2.1.5 (a)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Upper Macpherson strut pin or bush excessively worn Top mount (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage corroded and seriously weakened Lower securing cup corroded through (5.3.3 (b) (i)) | 1 |